Professional Documents
Culture Documents
Q1 Release Note
Release Note
Abstract
The intention of the release notes is to supply both internal and external
customers with information about the contents of the delivery. This information
should be used as a reference for software and hardware revisions, changes,
contents, and references to other documents where greater detail is required. The
purpose is not to duplicate information but to flag important information and
where possible reference other documents that need to be studied to ensure
successful implementation of the package.
© Ericsson AB 2019-2020
All rights reserved. The information in this document is the property of Ericsson.
Except as specifically authorized in writing by Ericsson, the receiver of this
document shall keep the information contained herein confidential and shall
protect the same in whole or in part from disclosure and dissemination to third
parties. Disclosure and disseminations to the receiver's employees shall only be
made on a strict need to know basis. The information in this document is
subject to change without notice and Ericsson assumes no responsibility for
factual inaccuracies or typographical errors.
2020-04-24
Contents
2020-04-24 2 (6)
1 Executive Summary
This release is intended for general cabinet controller use.
2 Revision History
Revision Prepared by Date Comments
A UABENGT 2020-04-07 First revision
3 Release Information
3.1 SW Identity
3.2 SW Content
This release includes Free and Open Source SW (FOSS) under the terms of GNU
General Public License (GPL) and GNU Lesser General Public License (LGPL).
2020-04-24 3 (6)
These programs are free software, which can be re-distributed and/or modified
under the terms of GPL respectively LGPL as published by the Free Software
Foundation.
To fulfill the GPL terms, the corresponding source code can be delivered upon
customer request through SW Gateway.
A list of all included FOSS can be found in document Free and Open Source
Software, included in the CPI library.
Security vulnerabilities are continuously monitored, and relevant fixes have been
applied.
2020-04-24 4 (6)
SCU supports new releases of ESCM based on these SW’s for 18 months after its
own release. This means that ESCM versions released until 21.Q3 will work with
this revision unless they are configured with new functionality not known to this
SCU version.
See 3.5.
Nothing new.
3.11 Alarms
3.12 OAM
3.13 License
2020-04-24 5 (6)
3.14 Common Restrictions and Limitations
3.14.1 Restrictions
Upgrading from R13B needs to be performed in two steps. First from R13B to
R15F, then from R15F to R20A.
HX96408 ESC Full maintenance mode on IPv6 Even when using IPv6 addressing, full maintenance mode
node available only through IPv4 still needs to use IPv4 addresses.
address
2020-04-24 6 (6)