Professional Documents
Culture Documents
Cat Prime Application Grease
Cat Prime Application Grease
Discover the Difference
Cat® Prime Application Grease is developed, tested, and approved
by Caterpillar to meet same high standards as all Genuine Cat Parts.
Corrosion Protection—Resists oxidation and protects metal against rust. Will not
corrode or damage steel, copper bearing alloys or conventional seal material.
Cat® Prime Application Grease
Grease Selection Guide
Cat Extreme Application Grease 1 Cat Extreme Application Grease - Desert Cat Prime Application Grease Cat Ball Bearing Grease 1
NLGI 1 NLGI 2 NLGI 2 NLGI 2
(-20 to 140ºC/-4 to 284ºF) (-20 to 140ºC/284ºF) (-20 to 140ºC/-4 to 284ºF) Temps above -20ºC/-4ºF)
With 5% Moly With 5% Moly With 3% Moly Without Moly
Cat Extreme Application Grease 2 Cat Extreme Application Grease - Arctic Cat Utility Grease 1
NLGI 2 NLGI 0.5 NLGI 2
(-15 to 140ºC/+5 to 284ºF) Temps down to -50ºC/58ºF) (-20 to 140ºC/-4 to 284ºF)
With 5% Moly With 5% Moly Without Moly
Typical Properties
NLGI 2 Recommended Use
Color Grey Black Cat Prime Application Grease is
Molybdenum Disulfide, % 3 recommended for grease fittings and
lubrication points in medium-load and
Operating Temperature Range, °C -20 to +140
medium-speed applications where
Operating Temperature Range, °F -4 to +284 operating temperatures range from
Base Oil Type Mineral -20°C to +140 °C (-4°F to +284 °F).
ASTM D445 Base Oil Viscosity 40°C, mm²/s 320
Thickener Type Lithium Complex
Health and Safety
ASTM D2265 Dropping point, °C 260 For information on proper use for health,
safety and environment, please refer to
ASTM D217 Penetration, worked 60, mm/10 280
the Material Safety Data Sheet (MSDS).
ASTM D1831 Roll stability, penetration change, mm/10 -3 Read and understand the MSDS before
ASTM D2266 4 Ball wear, scar diameter, mm 0.5 using this product. Always observe good
ASTM D2596 4 Ball weld load, kg 315 hygiene measures. For a copy of the
MSDS, contact us or visit the web at
ASTM D1743 Rust prevention Pass
www.catmsds.com.
ASTM D4048 Copper corrosion 1b
ASTM D1264 Water wash-out, 79°C, mass % 6
The values shown are typical values and should not be used as quality control parameters to either accept or reject product.
Specifications are subject to change without notice.
PEHJ0404
www.cat.com