Professional Documents
Culture Documents
www.deaconindustries.com
Deacon 327 Industrial Grade Silicone Sealant is
available in 4.5 gallon pails, 1 gallon pails, and 10.3 fl.
2. For stronger, more uniform bonds, apply a thin Oz. cartridges.
film of A-120 prime coat to all surfaces except rubber
and silicone rubber. Allow to air dry for 30 to 45 minutes USER’S PLEASE READ
at room temperature. (Full instructions are provided with
the prime coat). The information and data contained herein are believed
to be accurate and reliable; however, it is the user’s
CAUTION: A-120 prime coat is flammable and has no responsibility to determine suitability to use. Since the
FDA status. Keep away from heat and open flames. Use supplier cannot know all of the uses, or the conditions
only with adequate ventilation. of use to which these products may be put, no
warranties concerning the fitness or suitability for a
SEALING particular use or purpose are made.
Using Deacon 327 Industrial Grade Silicone Sealant You should thoroughly test any proposed use of our
in sealing applications follows approximately the products and independently conclude satisfactory
same step-by-step procedures as outlined for performance in your application.
bonding applications. After preparing the surface
and priming where required, the sealant is applied Likewise, if the manner in which our products are used
by forcing it in the joint or seam to obtain full contact requires government approval or clearance, you must
between sealant and surfaces. obtain it.
SPECIFICATIONS The supplier warrants only that its products will meet its
specifications. There is no warranty of merchantability
Meets or exceeds the following specifications: USDA or fitness for use, nor any other express or implied
for use in federally inspected Meat and poultry plants. warranty. The user’s exclusive remedy and the
FDA Regulation No.21 CFR 177.2600, TT-S-00230C supplier’s sole liability is limited to refund of the
(COM-NBS) Class A, and TT-S-001543A (COM- purchase price or replacement of any product shown to
NBS) Class A, Canadian 19-GP-9MA Type 1 and be otherwise than as warranted. The supplier will not be
MIL-A-46106. liable for incidental or consequential damages of any
kind.
WARNING Suggestions of uses should not be taken as
inducements to infringe any patents.
DIRECT CONTACT OF UNCURED SEALANT
IRRITATES EYES AND MAY IRRITATE SKIN.
OVEREXPOSURE TO VAPOR MAY IRRITATE
EYES, NOSE AND THROAT. Avoid eye and skin
contact. Use adequate ventilation. Do not handle
contact lenses with sealant on hands. IN CASE OF FOR INDUSTRIAL USE BY PROFESSIONALLY
EYE CONTACT, flush eyes with water for 15 min. TRAINED PERSONNEL ONLY.
Obtain medical attention. IN CASE OF SKIN CONSULT SDS & TECH SHEET FOR ALL SAFETY,
CONTACT, remove from skin and flush with water. TECHNICAL, & WARRANTY INFORMATION BEFORE
Sealant releases acetic acid (vinegar-like odor) USE. NOT RECOMMENDED FOR USE ON NUCLEAR
during cure. APPLICATIONS
SHIPPING LIMITATIONS
None.
LIMITED WARRANTY
PACKAGING
www.deaconindustries.com
TYPICAL PROPERTIES
Uncured
www.deaconindustries.com