You are on page 1of 105

i

ii
iii







1
2
3
4





5

6
4

1 2

7



1

8
9
10
11

12


3.

13

14
15

16

17

18
19
20
21
22

23
24
25
26
27
WiFi Name& Password WiFi Schedule Wireless Repeating

Channel & Bandwidth Transmit Power WPS

Beamforming

28

29



30
Wireless Router Wireless Router in Bridge Mode

31

32
2



33
5

34

35

36
2



3
4 2
2 2
5


37
6

2
7

38
39

40

41

42
43
44
FTP Server:
ftp://LAN IP address:port number
Or ftp://Medialinksettings.com

Samba Server:
Windows System: \\LAN IP address
Or \\Medialinksettings.com
MAC System: smb:// LAN IP address
Or smb:\\Medialinksettings.com

 To Connect a USB Drive

45

46
1

47
3

48
49
50
51
52
53
1
2

3
4


54

55

56

57

58
59
PPTP/L2TP Server
PPTP/L2TP Client enabled

60
1
2

❶ 3


61
1
2




62

63
1

64



65
4
5
6

66
1
2

67
1



2
3
4
5

7
8

68

69

70
1



71

72
1
2


73
74
1 2 3 4


75

76
1
2



77
78




79
80
81
82


83

84
85
86

87

88


89

90
91

92
Appendix




93
Appendix

❹ ❸

94
Appendix

95
Appendix

❹ ❸

96
Appendix

>
❸ ❷

97
Appendix

98
Appendix

99
Appendix

Hereby, Mediabridge Products, LLC. declares that AC1200 Smart Dual-Band Gigabit WiFi Router
is in compliance with the essential requirements and other relevant provisions of Directive
1995/5/EC. This equipment may be operated in: AT, BE, BG, CY, CZ, DK, EE, FI, FR, DE, GR,
HU, IS, IE, IT, LV,LI, LT, LU, MT, NL, NO, PL, PT, RO, SK, SI, ES, SE, CH, TR, GB.
Operations in the 5.15-5.25GHz band are restricted to indoor usage only.
This is a Class B product. In a domestic environment, this product may cause radio interference, in
which case the user may be required to take adequate measures.
NOTE: (1) The manufacturer is not responsible for any radio or TV interference caused by
unauthorized modifications to this equipment. (2) To avoid unnecessary radiation interference, it is
recommended to use a shielded RJ45 cable

This device is restricted to be used in the indoor.


This device complies with Part 15 of the FCC Rules. Operation is subject to the following two
conditions: (1) This device may not cause harmful interference, and (2) this device must accept any
interference received, including interference that may cause undesired operation.
This equipment has been tested and found to comply with the limits for a Class B digital device,
pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection
against harmful interference in a residential installation. This equipment generates, uses and can
radiate radio frequency energy and, if not installed and used in accordance with the instructions, may
cause harmful interference to radio communications. However, there is no guarantee that interference
will not occur in a particular installation. If this equipment does cause harmful interference to radio or
television reception, which can be determined by turning the equipment off and on, the user is
encouraged to try to correct the interference by one of the following measures:
— Reorient or relocate the receiving antenna.
— Increase the separation between the equipment and receiver.
— Connect the equipment into an outlet on a circuit different from that to which the receiver is

100
Appendix

connected.
— Consult the dealer or an experienced radio/TV technician for help.
FCC Caution: Any changes or modifications not expressly approved by the party responsible for
compliance could void the user's authority to operate this equipment.
This transmitter must not be co-located or operating in conjunction with any other antenna or
transmitter.
Radiation Exposure Statement
This device complies with FCC radiation exposure limits set forth for an uncontrolled environment
and it also complies with Part 15 of the FCC RF Rules.
This equipment complies with FCC radiation exposure limits set forth for an uncontrolled
environment. This equipment should be installed and operated with minimum distance 20cm between
the radiator & your body.
NOTE: (1) The manufacturer is not responsible for any radio or TV interference caused by
unauthorized modifications to this equipment. (2) To avoid unnecessary radiation interference, it is
recommended to use a shielded RJ45 cable.

101

You might also like