Professional Documents
Culture Documents
PM7345 - SATURN User Network Interface For PDH Applications
PM7345 - SATURN User Network Interface For PDH Applications
PM7345
S/UNI-PDH
SATURN User Network Interface for PDH Applications
FEATURES • Supports DS3 FEAC code insertion/ • Uses PMC-Sierra PM4341A T1XC T1,
detection and provides an integral PM6341 E1XC E1, or PM4351
• Monolithic single-chip ATM User- HDLC transceiver for path COMET framer/line interface devices
Network Interface (UNI) for DS3, E3, maintenance datalink processing. for DS1, E1, and J1 ATM UNI
DS1, and E1 Plesiochronous Digital applications.
• Supports G.832 Trail Trace and
Hierarchy (PDH) applications.
provides an integral HDLC transceiver • Software-compatible with the
• Provides on-chip DS3 (M23 or C-bit that supports the Network PM4341A T1XC, PM6341 E1XC,
parity) and E3 (G.751 and G.832) Requirement or General Purpose PM4351 COMET, PM5346 S/UNI®-
framers. datalinks. LITE, and PM7344 S/UNI-MPH.
• Implements the ATM direct cell • Provides detection of DS3/E3 Loss Of • Application-compatible with the
mapping into DS1, DS3, E1, and E3 Frame (LOF) and yellow alarm. PM8313 D3MX, PM4314 QDSX, and
transmission systems according to PM7323 RCMP-200.
• Accumulates BIP-8, framing and FEBE
ITU-T Recommendation G.804.
events. • Provides an 8-bit microprocessor
• Implements the ATM physical layer for interface for configuration, control, and
• Provides ATM cell scrambling/
Broadband ISDN according to ITU-T status monitoring.
descrambling, HCS error detection and
Recommendation I.432.
correction, HCS insertion, idle/ • Low power CMOS technology.
• Implements the Physical Layer unassigned ATM cell filtering and • Available in a high density 100-pin
Convergence Protocol (PLCP) for DS1 insertion, and accumulates counts of PQFP package (14 by 14 mm).
and DS3 transmission systems transmitted and received cells.
according to the ATM Forum User
Network Interface Specification and
• Provides DS3/E3 diagnostic loopback, APPLICATIONS
line loopback, payload loopback and • ATM Switches
ANSI TA-TSY-000773, TA-TSY-
ATM cell loopback. • ATM Routers
000772 and E1 and E3 transmission
• Provides support for an arbitrary rate • ATM Network Interfaces
systems according to ETSI 300-269
external transmission line interface up
and ETSI-270. • DSLAMs
to a maximum rate of 52 Mbit/s.
• Provides UTOPIA L1-compliant ATM- • ATM / SMDS Test Equipment
PHY interface.
BLOCK DIAGRA
C13/CADD/8KREF
TPOHCLK
TPOHINS
TPOHFP
TOHCLK
TDLCLK
TOHINS
TDLSIG
TOHFP
TIOHM
TCELL
TICLK
TPOH
TOH[
RPOH
D[7:0]
A[7:0]
ROHCLK
ROHFP
RPOHCLK
RPOHFP
RCELL
ALE
CSB
WRB
RDB
RSTB
INTB
RDLSIG
RDLCLK
DS3 or E3 Line
Interface with Analog
Egress Direction ATM Clock Recovery
Layer Devices and Interface
Circuitry
PM7345
S/UNI®-PDH
PM7323 SATURN® UNI for
RCMP-200 PDH Applications
ATM Layer Cell
Routing, Control,
Monitoring, and
Policing
UTOPIA or
SCI-PHY™
ATM Cell Bus Crystal Oscillator Clock 34.386
SCI-PHY™ MHz or 44.736 MHz
(Appended ATM
Cells)
Microprocessor Bus
PM4351
COMET Analog
Egress Direction ATM T1/E1/J1
Layer Devices and Interface
Framer/LIU
Circuitry
PM7345
S/UNI®-PDH
PM7323 SATURN® UNI for
RCMP-200 PDH Applications
ATM Layer Cell
Routing, Control,
Monitoring, and
Policing
UTOPIA or
SCI-PHY™
ATM Cell Bus
SCI-PHY™
Appended ATM
Cells)
Microprocessor Bus