Professional Documents
Culture Documents
Page 1 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 2 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 3 of 108
Revisions
00 New Release February 2008
01 Updated and added new photos February 2008
Notice
In accordance with our policy of product development, and in compliance with the GEMS VCR
program, Oshkosh Specialty Vehicles reserves the right to make changes in the equipment,
design, specifications, and materials of the product described herein. If there are any
inconsistencies between this manual and the mobile unit that inhibit serviceability, please contact
Oshkosh Specialty Vehicles for assistance.
This manual is one of two (2) information documents provided in the mobile unit. The
documentation package consists of:
Volume I – Site Guide, Operators Manual, and associated drawings
Volume II – Vendor Information
These volumes should be kept in the mobile unit at all times.
Any problems or questions related to the components or systems covered in this manual may be
directed to:
Oshkosh Specialty Vehicles
16745 South Lathrop Avenue
Harvey, Illinois
60426
USA
http://www.oshkoshsv.com/
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 4 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 5 of 108
Table of Contents
List of Revisions & Warnings .............................................................................. 3
Revisions .........................................................................................................................................3
Notice ..............................................................................................................................................3
Warnings & Safety Alert Conventions .............................................................................................4
Section 1: Introduction ...................................................................................... 11
Section 2: Safety Guidelines ............................................................................. 13
2.1 Operator’s General Safety Precautions..............................................................................14
2.2 Electrical Safety ..................................................................................................................15
2.3 Transportation Safety .........................................................................................................15
Section 3: Safety Systems ................................................................................. 17
3.1 Emergency Lighting............................................................................................................17
3.2 Fire Suppression (manual) .................................................................................................18
3.3 Marker Lights ......................................................................................................................19
3.4 System Shutdowns.............................................................................................................20
Manual Shutdown (Emergency Stop / A1 Stop) ........................................................................20
Phase / Voltage Shutdown ........................................................................................................20
3.5 Warning Lights....................................................................................................................20
Section 4: Mobile Unit Overview ....................................................................... 21
4.1 Breast Health Suite Overall ................................................................................................21
4.2 Reception / Registration Area Overall ................................................................................22
4.3 Air Ride Control Valve ........................................................................................................23
4.4 Canopies.............................................................................................................................24
4.5 Exterior Overall ...................................................................................................................25
4.6 Fuel Compartment..............................................................................................................26
4.7 Glad-hand Connections......................................................................................................27
4.8 Levels, Digital .....................................................................................................................28
4.9 Mobile Unit Controls ...........................................................................................................29
4.10 Phone & Data Line Connections.....................................................................................31
4.11 Rear Stabilizing Stands...................................................................................................32
4.13 Stair Assembly ................................................................................................................33
Section 5: Mobile Unit Setup Procedure........................................................... 35
5.1 Park the Mobile Unit ...........................................................................................................35
5.2 Lower the Front Stabilizing Legs ........................................................................................35
5.3 Disconnect the Tractor .......................................................................................................35
5.4 Install the Rear Stabilizing Stands......................................................................................36
5.5 Re-level the Mobile Unit .....................................................................................................36
5.6 Disconnect the Tractor Air and Electrical Lines..................................................................36
5.7 Lower the Auxiliary Support Legs.......................................................................................36
5.8 Connect to Shore Power ....................................................................................................37
5.9 Switch from Generator Power to Shore Power ..................................................................38
5.10 Connect the Phone and Data Lines................................................................................38
5.11 Connect the Water Hose.................................................................................................39
5.12 Install the Stair Assemblies.............................................................................................40
Stair Assembly ...........................................................................................................................40
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 6 of 108
5.13 Remove Restraining Hardware and Position Equipment for Use. .................................41
5.14 Door Canopy Deployment ..............................................................................................41
Section 6: Mobile Unit Transport Procedure.................................................... 43
6.1 Retract Door Canopies.......................................................................................................43
6.2 Secure all Equipment .........................................................................................................44
6.3 Remove and Store the Stair Assemblies ...........................................................................45
Standard Stair System............................................................................................................... 45
6.4 Disconnect and Switch from Shore Power to Generator Power ........................................45
6.5 Disconnect Phone and Data Lines.....................................................................................45
6.6 Disconnect the Water Hose ...............................................................................................46
6.7 Raise the Auxiliary Support Legs .......................................................................................46
6.8 Connect the Tractor Air and Electrical Lines......................................................................46
6.9 Remove the Rear Stabilizing Stands .................................................................................47
6.10 Connect the Tractor to the Mobile Unit...........................................................................47
6.11 Raise the Front Stabilizing Legs.....................................................................................47
6.12 Verify that the Mobile Unit is Ready for Transport..........................................................48
Section 7: Electrical System.............................................................................. 49
7.1 120/208 AC Electrical Panels.............................................................................................50
7.2 208V AC Phase Power Monitor .........................................................................................51
7.3 Facility Power Connection..................................................................................................52
7.4 Power Cable....................................................................................................................... 53
Section 8: Generator .......................................................................................... 55
8.1 Fuel System Priming Procedure: .......................................................................................57
8.2 Generator Start/Stop Switch ..............................................................................................57
Section 9: Humidity System .............................................................................. 59
9.1 System Operation...............................................................................................................59
9.2 Water Supply...................................................................................................................... 60
9.3 Humidity Controller............................................................................................................. 60
9.4 Humidity Settings ............................................................................................................... 60
9.5 Electrical Connections........................................................................................................61
9.6 Instructions ......................................................................................................................... 61
Section 10: HVAC System ................................................................................. 63
10.1 System Specifications and Descriptions ........................................................................64
10.2 Exterior HVAC Specifications .........................................................................................64
10.3 Interior HVAC Specifications ..........................................................................................65
10.4 Thermostat Temperature Setting....................................................................................65
Section 11: Wheel Chair Lift .............................................................................. 67
Section 12: Stabilizing Legs .............................................................................. 69
12.1 Stabilizing Stands ...........................................................................................................70
12.2 Rear Air Suspension System Controls ...........................................................................71
Section 13: Lighting System ............................................................................. 73
13.1 Emergency Lighting ........................................................................................................73
13.2 Exterior Lighting..............................................................................................................74
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 7 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 8 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 9 of 108
List of Figures
Figure 1: The Hologic Selenia Mammography Unit ..........................................................................11
Figure 2: Emergency Lighting ...........................................................................................................17
Figure 3: Fire Extinguisher ................................................................................................................18
Figure 4: Marker Lights .....................................................................................................................19
Figure 5: Emergency Shutdown Buttons ..........................................................................................20
Figure 6: Breast Health Suite Overall ...............................................................................................21
Figure 7: Registration Area Overall...................................................................................................22
Figure 8: Air Ride Control Valve .......................................................................................................23
Figure 9: Door Canopies ...................................................................................................................24
Figure 10: Exterior Overall ................................................................................................................25
Figure 11: Fuel Compartment ...........................................................................................................26
Figure 12: Glad Hand Connections...................................................................................................27
Figure 13: Digital Levels....................................................................................................................28
Figure 14 Mobile Unit Controls .........................................................................................................30
Figure 15: Phone & Data Line Connections .....................................................................................31
Figure 16: Rear Stabilizing Stands ...................................................................................................32
Figure 17: Front Stabilizing Legs and Auxiliary Support Legs ..........................................................32
Figure 18: Stair Assembly.................................................................................................................33
Figure 19: 208V Power Control Panel ..............................................................................................37
Figure 20: Humidifier Tank Fill ..........................................................................................................39
Figure 21: Mobile Barrier & Roll Around Sink Restraints..................................................................44
Figure 22: 120/208V AC Electrical Panel..........................................................................................50
Figure 23: 208V AC Phase Power Monitor .......................................................................................51
Figure 24: Shore Power Connection.................................................................................................52
Figure 25: Generator Compartment..................................................................................................56
Figure 26: Advanced Digital Control .................................................................................................57
Figure 27: Humidity Controller ..........................................................................................................60
Figure 28: A/C Units..........................................................................................................................63
Figure 29: Thermostat Temperature Control ....................................................................................65
Figure 30: Wheel Chair Lift ...............................................................................................................67
Figure 31: Front Stabilizing Leg Assembly .......................................................................................69
Figure 32: Rear Stabilizing Stands ...................................................................................................70
Figure 33: Air Bag Controls...............................................................................................................71
Figure 34: Emergency Lighting .........................................................................................................73
Figure 35: Compartment Light ..........................................................................................................74
Figure 36: Entry Door Lighting ..........................................................................................................75
Figure 37: Interior Overall Lighting....................................................................................................76
Figure 38: Breast Health Suite Overall Lighting Controls .................................................................77
Figure 39: Warning Lights .................................................................................................................78
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 10 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 11 of 108
Section 1: Introduction
This manual is intended to instruct and assist personnel already qualified in the
proper installation of the mobile unit. This manual is not intended to enable
persons unfamiliar with the mobile unit to perform the setup and transport
procedures.
An outside radiation physicist consultant determines the x-ray shielding based
upon unit layout that is provided by Oshkosh Specialty Vehicles and scatter
patterns provided the medical equipment manufacturer. It is the user’s
responsibility to ensure proper maintenance of the x-ray shielding. It is the
recommendation of Oshkosh Specialty Vehicles that the end user has the x-ray
testing completed on an annual basis to ensure that the mobile unit still meets
the minimum requirements.
This manual contains the basic information needed to setup, transport, and service the mobile unit.
This mobile unit was designed to operate within certain limitations and specifications. When
performing the setup or transport procedures for the mobile unit, follow the proper logical steps that
have been outlined in this manual. The drawings in this manual are representative of this product.
In accordance with our program of continued product development, designs and specifications are
subject to change without notice.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 12 of 108
As part of Oshkosh Specialty Vehicles’ on-going program to improve its products and
service, (and their effectiveness in enhancing safety, reliability, performance, productivity,
and the useful service life of the equipment) Oshkosh Specialty Vehicles reserves the right
to implement product changes and disseminate changes in design and service information
without notice or recourse.
For questions regarding the Operation or Service of this unit call Oshkosh Specialty Vehicles at
800-839-0630.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 13 of 108
This safety section contains important information in regards to general safety guidelines that
should be followed. Before attempting to service the mobile unit, read this safety section as well as
all other safety sections found in applicable manufacturers’ manuals in the component literature
binder.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 14 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 15 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 16 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 17 of 108
This safety section contains important information about the safety systems that have been built
into the mobile unit to protect all personnel and equipment. Before attempting to service the mobile
unit, read this safety section as well as all other safety sections found in applicable manufacturers’
manuals in the component literature binder.
3.1 Emergency Lighting
In the event that the main AC power fails, five dual beam emergency lights are provided in the
Breast Health Suite, Reception Area, and Main Hallway. These lights will automatically illuminate
when the main AC power is lost. The emergency lighting system is wired into a 120V AC electrical
system that allows the lights internal circuitry to keep their batteries at 100% charge. The
emergency lights will illuminate the exit doors last for approximately 90 minutes.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 18 of 108
Locate on the right hand side of Main entrance Located to the left of the entrance door of the
door as you enter the unit. Breast Health Suite room.
Figure 3: Fire Extinguisher
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 19 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 20 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 21 of 108
The components of the mobile unit have been divided into alphabetical order following a brief
description of the unit. With each component a picture and description will be found to better
illustrate the components of the mobile unit. Additional components of the mobile unit can be found
within the remaining chapters.
4.1 Breast Health Suite Overall
The Breast Health Suite houses the system components that support the mammography medical
system. In this room, the operator’s console can be found, along with the system controls and
cabinets for storage.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 22 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 23 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 24 of 108
4.4 Canopies
The canopies are positioned above the doors to provide shelter from the elements.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 25 of 108
Left Side
Right Side
Figure 10: Exterior Overall
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 26 of 108
Push Button
Fuel Gauge
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 27 of 108
Key lock
Box
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 28 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 29 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 30 of 108
X-Ray Room Light Switches: ON / OFF light switch for X-Ray Room lights.
Exterior and Interior Light ON / OFF light switch for the exterior lights.
Switches:
Humidistat: Humidity information of the mobile unit.
Thermostat Temperature controls for the mobile unit.
E Stop: Emergency stop button for the medical system.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 31 of 108
Phone Connections The phone connections that are utilized are RJ-45. The
connections utilize CAT-5E cable and can be connected
directly to the facility.
Data Connections The data connections that are utilized are RJ-45. The
connections utilize CAT-5E cable and can be connected
directly to the facility.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 32 of 108
Stabilizing
Leg
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 33 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 34 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 35 of 108
The Hologic Selenia medical system requires the HVAC system to be supplied
power at all times. During transit of the mobile unit via the generator and when
the unit is in the parked position via shore power.
The stabilizing legs and rear suspension are not to be used to raise the mobile
unit off the ground. The legs are meant only to level the unit and place it in a
parked position. If the legs are used in an attempt to raise the mobile unit from
the ground, serious damage may occur to the mobile unit.
A checklist can be found in Appendix A that may be used as a guideline for the
following procedure.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 36 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 37 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 38 of 108
Open the lower compartment door that houses the electrical components to access the Power
Supply Control Panel. Refer to Figure 19: 208V Power Control Panel.
Turn the unit power selector on the reversing contactor panel from “Generator1-Lower or 2-Upper
to “Line”. Be certain to pause for five seconds in the "OFF" Position between selections.
The two indicators on this panel will illuminate according to the power that is received.
If the supply of power is good, the green indicator labeled “208V AC OKAY” will illuminate.
If the supply of power is experiencing problems, such as being out of phase, the red indicator
labeled “208V AC FAULT” will illuminate.
Since minor fluctuations in power are common, the “208V AC FAULT” may briefly flicker. This is to
be expected. If the “208V AC FAULT” indicator light stays illuminated, switch back to generator
power and contact a qualified electrician before operating the medical system.
If the power supply is good, the selector for the generator can be moved to the “STOP” position.
Once this has been done, the generator will enter into a cooling phase and continue running for
approximately two minutes.
Turn the Generator selector switch to the “OFF” position, back to "ON" then to "OFF" again to shut
down the generator.
The Power Cable could present a trip hazard that could result in personal
injury. Care should be taken to ensure that the cable is routed properly to
minimize its potential as a trip hazard.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 39 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 40 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 41 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 42 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 43 of 108
If the mobile unit is moved without the rear air suspension functioning properly,
irreparable damage can occur to the mobile unit.
The Hologic Selenia medical system requires the HVAC system to be supplied
power at all times. During transit of the mobile unit via the generator and when
the unit is in the parked position via shore power.
The stabilizing legs and rear suspension are not to be used to raise the mobile
unit off the ground. The legs are meant only to level the unit and place it in a
parked position. If the legs are used in an attempt to raise the mobile unit from
the ground, serious damage may occur to the mobile unit.
Before transporting the mobile unit, check to verify all warning lights as well as
all exterior marker lights are working correctly.
A checklist can be found in Appendix A that may be used as a guideline for the
following procedure.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 44 of 108
Bungee cord
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 45 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 46 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 47 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 48 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 49 of 108
The entire electrical system is installed in conformance with the National Electric Code.
The system is completely installed in the factory. Service access is gained through the underbody
compartments of the mobile unit with thin wall conduit and/or wire-mold sized to accept the
required service entrance conductors used throughout the mobile unit.
All electrical materials, devices, appliances, fittings, and other equipment are approved and listed
by Underwriters’ Laboratories, Inc. (UL).
All required tags, labels and rating nameplates are permanently installed in their proper locations
before the mobile unit leaves the factory.
There are several panels used in the electrical system.
One 120/208V AC distribution panel that is located at the rear of the Scan Room in the mobile unit.
This panel is responsible for all AC powered components aboard the mobile.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 50 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 51 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 52 of 108
Although the shore power connection in not an actual physical feature of the mobile unit, it is an
integral part of the daily operations.
Oshkosh Specialty Vehicles The plug that is provided by Oshkosh Specialty Vehicles
Connector: for connection to the shore power receptacle.
Power Cable: The cable that runs between the shore power connections
and the 208V AC electrical panel.
Shore Power Disconnect: The shore power disconnect terminates the power to the
receptacle. This must be in the “OFF” position when
connecting to the receptacle.
Shore Power Receptacle Outlet: The receptacle outlet that the shore facility has installed
for use with the Oshkosh Specialty Vehicles connector
and power cable.
Shore Power Unit: The complete shore power assembly.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 53 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 54 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 55 of 108
Section 8: Generator
The medical system requires the HVAC system to be supplied power at all
times. During transit of the mobile unit via the generator and when the unit is in
the parked position via shore power.
When servicing the unit be certain that a first aid kit and fire extinguisher are
within reach at all times.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 56 of 108
The mobile unit is equipped with two 40 KVA generators that are mounted on the front of the unit.
The generator supplies power to the unit during transport. The generators can also be able to
power the medical system so the medical procedures can take place when shore power is
unavailable.
The generator oil, as well as the oil filter, air filter, and fuel filter must be changed every 250 hours
or six months of service, whichever comes first. The number of hours the generator has been in
operation can obtained by checking the microprocessor located on top of the staging unit in the
generator compartment.
Once a year, the fuel separator should be checked for contamination and accumulation of debris.
For additional information, refer to the Oshkosh Specialty Vehicles VOL II Vendor Information
binder for the product manual.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 57 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 58 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 59 of 108
All settings for the humidity system are preset at the factory. Under no
circumstances should factory presets be altered.
Proper humidity levels must be maintained to protect sensitive electronic
equipment.
The humidifier is responsible for maintaining the humidity levels within the mobile unit. The settings
for the humidifier are set to meet the medical system manufacturers’ specifications. Under no
circumstances should the settings of the humidifier be altered. In order for the humidifier to function
properly, the water tank level must be maintained at all times.
Exterior Connection: The facility must provide a fresh water supply for use with the mobile unit.
The incoming supply is then attached to the connection.
Humidifier: The humidifier provides the required humidity to the mobile unit per the
medical manufacturer’s requirements.
Humidity Controller: The humidistat is responsible for the internal humidity of the mobile unit.
The setting is preset at the factory to comply with the medical system
manufacturers requirements.
Humidity Sensor: Maintains an accurate reading of the humidity levels inside of the mobile
unit.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 60 of 108
• One 1” female garden hose coupling for the water supply from the exterior of the mobile
unit. (incoming)
• One 0.5” outer diameter copper drain line from the steam cylinder for automatic drain
cycles. The drain penetrates the floor of the mobile unit in order to empty to the exterior.
(drainage)
9.3 Humidity Controller
All settings for the humidity system are preset at the factory. Under no
circumstances should factory presets be altered.
The humidity controller is located in Breast Health Suite room above the electrical panel wall next
to the air filter access door. The relative humidity setting for the mobile unit is 35%. The humidifier
must not be altered from its factory setting.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 61 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 62 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 63 of 108
The HVAC system is critical to the operation and life of the medical system.
The medical system operates within strict specifications regarding temperature
and humidity. All aspects of the HVAC system such as damper settings,
venting, component set points, and sensor placement are adjusted for
optimum operation. Under no circumstances should these settings be altered.
The Hologic Selenia medical system requires the HVAC system to be supplied
power at all times. During transit of the mobile unit via the generator and when
the unit is in the parked position via shore power.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 64 of 108
Two air conditioning units are used to maintain the internal environment of the mobile unit. Both air
conditioners come from the factory preset to the specifications required by the medical system
manufacturer. Under no circumstances should the factory presets be changed or altered from their
factory setting. Irreparable damage can occur to the medical system if this is done.
The HVAC system is designed specifically to maintain only the internal environment of the mobile
unit. The HVAC system is not designed to handle areas outside of the mobile unit, such as
adjoining corridors or hallways. It is important to keep all exterior doors closed at all times. All
interior doors, computer doors, partitions, and damper settings, must be in the intended positions
before running the medical equipment. Do not attempt to store any boxes or items in the mobile
unit, as this will interrupt the intended airflow requirements.
In order to ensure proper operation of the HVAC system at all times, refer to Section 14: General
Maintenance and Section 15: Specific Maintenance.
10.1 System Specifications and Descriptions
The HVAC system is completely designed and installed in full conformance with all applicable
codes.
The HVAC system utilizes forced air.
The HVAC utilizes electricity as the source of power.
Heat producing appliances must be approved by Underwriters Laboratories, Inc. (U.L) and installed
in accordance with the terms on their listings.
The air ducts are constructed of approved materials and installed in conformance with all
applicable codes.
Air conditioning and heating registers are installed in accordance with the approved plans.
Return air is provided as required and is in full conformance with all applicable codes.
All warning and identification labels as required are installed at the factory.
All aspects of the HVAC system such as damper settings, venting, component set points, and
sensor placement are adjusted for optimum operation. Under no circumstances should these
settings be altered.
Two separate and individually controlled units provide air conditioning and heating for the mobile
unit.
The air conditioning ductwork is lined with a sound absorbent material for reduced noise and
operator and patient comfort.
10.2 Exterior HVAC Specifications
The HVAC system is designed to work within certain limitations. The ambient exterior temperatures
must be within the range of -20°F to 110°F.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 65 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 66 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 67 of 108
The mobile unit contains a Ricon Wheel Chair Lift (S5505), which is used to move personnel from
the ground level to the floor level of the mobile unit. The wheel chair lift has a maximum design
capacity of 800 lbs and a working capacity of 434 lbs. The lifting height is 46”.
Refer to the Service / Operations Manual, Volume II Vendor Information for Installation, Service
and Maintenance requirements.
Wheel Chair Lift In the stowed Switch to turn the power on for
Lift Pendent
position the Wheel Chair Lift
Wheel Chair Lift Deployed Wheel Chair Lift at floor level Wheel Chair Cycle
Figure 30: Wheel Chair Lift
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 68 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 69 of 108
Under no circumstances should the stabilizing legs and the rear air suspension
be used to lift the mobile unit from the ground. If any attempt is made to raise
the unit from the ground using the only the stabilizing legs and the rear air
suspension, serious damage can occur to the suspension system of the mobile
unit.
Both the stabilizing legs and the auxiliary support legs can be found at the front and rear of the unit.
The stabilizing legs installed on this mobile unit are only for the purpose of parking and stabilizing
the mobile unit. Please refer to the product manual located in Volume II of the literature provided by
Oshkosh Specialty Vehicles for additional information.
Stabilizing Leg Controls: The control box houses the stabilizing leg controls.
Stabilizing Leg: Allows the mobile unit to be parked without the tractor being
attached to the unit.
Digital Levels: Allows the mobile unit to be leveled both front to back and side
to side.
Lever 1: Right side leg.
Lever 2: Left side leg.
Air Suspension Control Switch The “DN” position deflates the air bags. The “UP” position
inflates the air bags for normal ride.
Pump ON / OFF Switch The switch must be held in the ON position when extending or
retracting the legs.
Auxiliary Support Legs: The auxiliary support legs provide a fixed leg for use as a
backup in case the stabilizing legs fail.
Sand Shoe: Helps prevent the stabilizing legs from sinking due to weight.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 70 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 71 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 72 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 73 of 108
The lighting provided for the mobile unit can be divided into either interior lighting, or exterior
lighting. Listed below are explanations concerning the lighting provided.
13.1 Emergency Lighting
In the event that the main AC power fails, three emergency lights are provided. These lights will
automatically illuminate when the main AC power is lost. The lights are located in the Reception
Area, Main Hallway, and Breast Health Suite. The emergency lighting system is wired into a 120V
AC electrical system that allows the lights internal circuitry to keep its batteries at 100% charge.
The emergency lights will illuminate the Exit doors and last for approximately 90 minutes.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 74 of 108
The exterior lighting system can be divided as follows. For additional information of the warning
lights Please refer to Appendix B: Troubleshooting.
Underbody Compartment Lighting
Located inside of the underbody compartments there are wall mounted halogen lights
connected to timers. The timers allow the lights to be set for up to 30 minutes before
automatically turning off. There is one light provided on each side of the underbody.
In addition, since the fuel compartment is sealed off from the others, a push button dome
light has been included in this compartment.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 75 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 76 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 77 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 78 of 108
Power Loss
Strobe Light
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 79 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 80 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 81 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 82 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 83 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 84 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 85 of 108
A power washer should never be used to clean the A/C units. Serious damage
to the A/C coils may occur.
When servicing the unit be certain that a first aid kit and fire extinguisher are
within reach at all times.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 86 of 108
The 70 gal. fresh water tank supplies the humidifier with water. The water level must be maintained
at all times.
1. Check the water tank to determine the water level.
2. Attach one end of a hose to the exterior water tank fill valve and the other end to the shore
supply.
3. Turn on the water source to begin filling the tank.
4. After the water tank is full, turn off the water source.
5. Detach the hose at both ends and place in the underbody storage compartments.
15.5 HVAC System
The HVAC system is critical to the operation and life of the equipment. The
medical equipment operates within strict limits regarding temperature and
humidity. All aspects of the HVAC system such as baffling, venting, component
set points, and sensor placement are adjusted for optimum operation. Under
no circumstances should any aspect of the HVAC system be altered from
factory specifications.
The HVAC system is designed specifically to maintain only the internal environment of the mobile
unit. The HVAC system is not designed to handle areas outside of the mobile unit such as
adjoining corridors or hallways.
1. It is important to be sure that the doors, partitions, and baffling are in the intended positions
before running the medical system.
2. Do not attempt to store boxes, or any other items near computer system air inlets or in the
aisles. Such actions will disrupt the intended airflow requirements.
3. A qualified A/C technician must check the A/C condensers every month. Refer to the Air
Conditioning Owner’s Manual for more information.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 87 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 88 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 89 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 90 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 91 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 92 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 93 of 108
Appendix B: Troubleshooting
If any of the following troubleshooting guides do not correct the problem, or if the problem worsens,
please refer to the Oshkosh Specialty Vehicles VOL II Vendor Information binder for the product
manual, the Oshkosh Specialty Vehicles VOL I Service/Operation Manual binder for a list of local
service representatives, or contact Oshkosh Specialty Vehicles for service.
AC Power Indicator Light is off…
If the AC Power Indicator Light is “OFF” then the mobile unit is not receiving AC power. The mobile
unit must have power at all times. If the mobile unit is on site, shore power must be connected.
If the mobile unit is being transported, then the vehicle must be stopped and the following items
checked. For any additional information, please contact Oshkosh Specialty Vehicles.
Generator power is connected when the A/C power Off strobe light illuminates:
1. Verify that the fuel tank has fuel.
2. Verify that the Generator selector has been moved to the “Start” position.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 94 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 95 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 96 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 97 of 108
The HVAC system is critical to the operation and life of the equipment. The
medical equipment operates within strict limits regarding temperature and
humidity. All aspects of the HVAC system such as baffling, venting, component
set points, and sensor placement have been adjusted for optimum operation.
Under no circumstances should any aspect of the HVAC system be altered
from factory specifications.
There are two set points for the HVAC system. These points are set at the factory and should not
be changed under any circumstances. Altering these points can result in damage to the medical
equipment.
Temperature Controller Settings
The Controller has only two settings: AC or HC.
Humidity Settings
The humidistat set point is 35% relative humidity.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 98 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 99 of 108
Category 1
Visual Checks – Check for the most common occurrences.
Is the circuit breaker, in the 208V AC electrical panel, in the “ON” position?
Are the Mammography System UPS 60 amp circuit breakers in the 120/208V AC electrical panel in
the “ON” position?
Category 2
Component Checks – (some tools may be required).
Check the emergency off button in the Breast Health Suite, N.O.?
For additional troubleshooting, please contact Oshkosh Specialty Vehicles for assistance.
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 100 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 101 of 108
Affected Personnel to notify when the Specialty Vehicles Trailer is to be Locked Out:
Name/Department: Location:
Production employees In the vicinity of the trailer
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 102 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or
wholly, for any purpose inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without
written permission of Oshkosh Specialty Vehicles.
10296-D01-01
Page 103 of 108
Service Technician:
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or wholly, for any purpose
inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without written permission of Oshkosh Specialty
Vehicles.
10296-D01-01
Page 104 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or wholly, for any purpose
inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without written permission of Oshkosh Specialty
Vehicles.
10296-D01-01
Page 105 of 108
Comment :
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or wholly, for any purpose
inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without written permission of Oshkosh Specialty
Vehicles.
10296-D01-01
Page 106 of 108
Signature of Technician:
____________________________________ Date:
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or wholly, for any purpose
inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without written permission of Oshkosh Specialty
Vehicles.
10296-D01-01
Page 107 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or wholly, for any purpose
inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without written permission of Oshkosh Specialty
Vehicles.
10296-D01-01
Page 108 of 108
The information contained in this booklet is the property of OSV. The contents are confidential. They may not be used, either partially or wholly, for any purpose
inconsistent with the purpose for which it was produced. The contents may not be reproduced or disclosed without written permission of Oshkosh Specialty
Vehicles.