You are on page 1of 11

SANJIVANI RURAL EDUCATION SOCITY ,

KOPARGAON
SANJIVANI K.B.P.POLYTECHNIC

MICROPROJECT ON
ADJUSTABLE POWER SUPPLY
*SUBMITTED TO*
M.S.B.T.E.

*SUBMITTED BY*
1. RANDHE VISHAL D.
2. POTE AKANKSHA D.
3. SHINDE NIKITA S.
4. DHADIWAL DEEP D.
5. BOTHE ATHARVA R.

GROUP ID : EJ ROCKERS

UNDER THE GUIDANCE OF


PROF. D. B. BORSE
DEPARTMENT OF ELECTRONICS &
TELECOMMUNICATION
CERTIFICATE
DEPARTMENT OF ELECTRONICS AND TELECOMMUNUCATION
S.K.B.P. POLYTECHNIC, KOPARGAON

This is to Certify That Project Entitled

ADJUSTABLE POWER SUPPLY


Submitted by
1. Randhe Vishal D. 3. Pote Akanksha D.
2. Dhadiwal Deep D. 4. Shinde Nikita S.
5. Bothe Atharva R.

Are a bonafide work carried out by above students under the supervision
of Mr. Borse sir and it is submitted towards the partial fulfilment of the requirement
of MSBTE , Mumbai for the award of Diploma in Electronics and Telecommunication
Engineering.

PROF. BORSE SIR PROF. KAKADE SIR


 INTRODUCTION

To covert the PSU into a variable power supply, use an


LM 338K or LM 317 adjustable voltage regulator IC as
shown in fig. connect +12V and -12V supplies from the
PSU to this circuit so that we get 1.2V to +23V
maximum output using VRI potentiometer. But the
current output will reduce to 500mA because the
output current of -12V output is 500mA only.
 BLOCK DIAGRAM

Voltage
regulator with
𝑉𝑖𝑛 =+12 V IC LM 317 𝑉𝑜𝑢𝑡 = +1.2V to 23v

Fig : Block diagram of adjustable voltage regulator


 CIRCUIT DIAGRAM
 CIRCUIT LAYOUT

Fig : Layout of adjustable voltage regulator


 Working of circuit diagram

• The practical regulator using LM317 is as shown


in Fig.
• Filter capacitors are necessary only if LM 317 is
located at a distant location from the filter
capacitor of unregulated input power supply.
• If LM317 is far away from input power supply,
then a 100 uF disc type or 1 uF. tantalum
capacitor should be used at the input of LM317 as
a filter as shown in Fig.
• The output capacitor C is optional. We can
connect to improve the transient response. C is a
large value electrolytic capacitor
• which should be in the range of 1 to 1000 F.
• The adjustment terminal ADJ of IC LM 317 is
bypassed with a capacitor C as shown in Fig.
 Technical feature

 LM 317 has many future prospects. By using


LM 317 we can easily overcome the noise
effect of the circuit .
 By changing the load resistance and voltage the
noise effect further be diminished. So that we
get an error free output voltage. In other words
LM 317 is highly proefficient in making a circuit
error free and flawless.
 Component list

Sr. Name of component Value Cost


no.
1) IC LM 317 5 /-
2) Diode IN 4007 3/-
3) Resistor 200 Ohm 5/-
4) Capacitor 100uf ,10uf 10/-
5) Pot 4.7k Ohm 7/-
Total 30/-
 CONCLUTION

LM317 is very useful integrated circuit


used in power supplies. But when capacitor and
protective circuit, protecting the highly complicate
circuits from being damaged . Variable voltage
regulator can used for different purpose .
 Reference

• www.circuitstoday.com
• www.electroincproject.com
• Magazine- Electronics for U
• Applied electronics by J.S. katare

You might also like