Professional Documents
Culture Documents
COMPANY IDENTIFICATION
DOW CHEMICAL PACIFIC
(SINGAPORE) PRIVATE LIMITED
260 ORCHARD RD, #18-01 THE HEEREN
SINGAPORE 238855
SINGAPORE
2. HAZARDS IDENTIFICATION
GHS Classification
Serious eye damage/eye irritation - Category 2
Hazard statements
Causes serious eye irritation.
Precautionary statements
Prevention
Avoid breathing spray.
Wash skin thoroughly after handling.
Use only outdoors or in a well-ventilated area.
Wear eye protection/ face protection.
Response
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing.
If eye irritation persists: Get medical advice/ attention.
Other hazards
No data available
3. COMPOSITION/INFORMATION ON INGREDIENTS
Eye contact: Immediately flush eyes with water; remove contact lenses, if present, after the first 5
minutes, then continue flushing eyes for at least 15 minutes. Obtain medical attention without delay,
preferably from an ophthalmologist. Suitable emergency eye wash facility should be immediately
available.
Page 2 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Most important symptoms and effects, both acute and delayed: Aside from the information found
under Description of first aid measures (above) and Indication of immediate medical attention and
special treatment needed (below), any additional important symptoms and effects are described in
Section 11: Toxicology Information.
5. FIREFIGHTING MEASURES
Suitable extinguishing media: Water spray Alcohol-resistant foam Carbon dioxide (CO2) Dry
chemical
Unusual Fire and Explosion Hazards: Exposure to combustion products may be a hazard to
health.
Special protective equipment for firefighters: In the event of fire, wear self-contained breathing
apparatus. Use personal protective equipment.
Environmental precautions: Do not release the product to the aquatic environment above defined
regulatory levels Prevent further leakage or spillage if safe to do so. Prevent spreading over a wide
area (e.g. by containment or oil barriers). Retain and dispose of contaminated wash water. Local
authorities should be advised if significant spillages cannot be contained.
Methods and materials for containment and cleaning up: Soak up with inert absorbent material.
Clean up remaining materials from spill with suitable absorbant. Local or national regulations may
apply to releases and disposal of this material, as well as those materials and items employed in the
cleanup of releases. You will need to determine which regulations are applicable. For large spills,
Page 3 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
provide dyking or other appropriate containment to keep material from spreading. If dyked material can
be pumped, Sections 13 and 15 of this SDS provide information regarding certain local or national
requirements.
See sections: 7, 8, 11, 12 and 13.
Conditions for safe storage: Keep in properly labelled containers. Store in accordance with the
particular national regulations.
Do not store with the following product types: Strong oxidizing agents.
Unsuitable materials for containers: None known.
Although some of the components of this product may have exposure guidelines, no exposure would
be expected under normal handling conditions due to the physical state of the material.
Exposure controls
Engineering controls: Use local exhaust ventilation, or other engineering controls to maintain
airborne levels below exposure limit requirements or guidelines. If there are no applicable exposure
limit requirements or guidelines, general ventilation should be sufficient for most operations. Local
exhaust ventilation may be necessary for some operations.
Page 4 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Page 5 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
NOTE: The physical data presented above are typical values and should not be construed as a
specification.
Acute toxicity
Acute oral toxicity
Very low toxicity if swallowed. Harmful effects not anticipated from swallowing small amounts.
Skin corrosion/irritation
Brief contact is essentially nonirritating to skin.
Page 6 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Sensitization
For skin sensitization:
No specific, relevant data available for assessment.
Carcinogenicity
No specific, relevant data available for assessment.
Teratogenicity
No specific, relevant data available for assessment.
Reproductive toxicity
No specific, relevant data available for assessment.
Mutagenicity
Contains a component(s) which were negative in in vitro genetic toxicity studies. Contains
component(s) which were negative in animal genetic toxicity studies.
Aspiration Hazard
Based on physical properties, not likely to be an aspiration hazard.
alpha-octadecyl-omega-hydroxy-polyglycolether
Acute inhalation toxicity
LC50, Rat, 4 Hour, dust/mist, > 0.22 mg/l No deaths occurred at this concentration.
Ecotoxicity
alpha-octadecyl-omega-hydroxy-polyglycolether
Acute toxicity to fish
Material is moderately toxic to aquatic organisms on an acute basis (LC50/EC50 between 1
and 10 mg/L in the most sensitive species tested).
For similar material(s):
LC50, Leuciscus idus (Golden orfe), 96 Hour, 4.1 mg/l, Method Not Specified.
Page 7 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Toxicity to bacteria
For similar material(s):
EC50, Bacteria (active sludge), 1,000 mg/l
For similar material(s):
EC10, Bacteria (active sludge), 2 mg/l
For similar material(s):
EC10, Pseudomonas putida, 16.9 Hour, 10,000 mg/l, DIN 38412
alpha-octadecyl-omega-hydroxy-polyglycolether
Biodegradability: For similar material(s): Material is expected to be readily biodegradable.
10-day Window: Pass
Biodegradation: 60 %
Exposure time: 28 d
Method: OECD Test Guideline 301F or Equivalent
10-day Window: Pass
Biodegradation: 83.6 %
Exposure time: 28 d
Method: OECD Test Guideline 301B
Bioaccumulative potential
Page 8 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
alpha-octadecyl-omega-hydroxy-polyglycolether
Bioaccumulation: For similar material(s): Bioconcentration potential is moderate (BCF
between 100 and 3000 or Log Pow between 3 and 5).
Partition coefficient: n-octanol/water(log Pow): 4.57 Method Not Specified.
Bioconcentration factor (BCF): < 400 Pimephales promelas (fathead minnow)
Mobility in Soil
alpha-octadecyl-omega-hydroxy-polyglycolether
No relevant data found.
alpha-octadecyl-omega-hydroxy-polyglycolether
This substance has not been assessed for persistence, bioaccumulation and toxicity (PBT).
alpha-octadecyl-omega-hydroxy-polyglycolether
This substance is not on the Montreal Protocol list of substances that deplete the ozone layer.
This product when disposed of in its unused and uncontaminated state should be treated as a
hazardous waste.
Page 9 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Workplace Classification
This product is classified as hazardous according to Singapore Standards, Act and Regulations.
The following statutes, regulations and standards have the related prescribes on chemicals in
terms of safe use, storage, transportation, loading and unloading, classification and symbol
etc.
Workplace Safety and Health Act & Workplace Safety and Health (General Provisions) Regulations
Environmental Protection and Management Act and Environmental Protection and Management
(Hazardous Substances) Regulations
Chemical Weapons Prohibition Act
Revision
Identification Number: 4022132 / A167 / Issue Date: 03/14/2018 / Version: 3.0
Most recent revision(s) are noted by the bold, double bars in left-hand margin throughout this
document.
Page 10 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Mutagen or Reproductive Toxicant; CPR - Controlled Products Regulations; DIN - Standard of the
German Institute for Standardisation; DSL - Domestic Substances List (Canada); ECx - Concentration
associated with x% response; ELx - Loading rate associated with x% response; EmS - Emergency
Schedule; ENCS - Existing and New Chemical Substances (Japan); ErCx - Concentration associated
with x% growth rate response; ERG - Emergency Response Guide; GHS - Globally Harmonized
System; GLP - Good Laboratory Practice; IARC - International Agency for Research on Cancer; IATA
- International Air Transport Association; IBC - International Code for the Construction and Equipment
of Ships carrying Dangerous Chemicals in Bulk; IC50 - Half maximal inhibitory concentration; ICAO -
International Civil Aviation Organization; IECSC - Inventory of Existing Chemical Substances in China;
IMDG - International Maritime Dangerous Goods; IMO - International Maritime Organization; ISHL -
Industrial Safety and Health Law (Japan); ISO - International Organisation for Standardization; KECI -
Korea Existing Chemicals Inventory; LC50 - Lethal Concentration to 50 % of a test population; LD50 -
Lethal Dose to 50% of a test population (Median Lethal Dose); MARPOL - International Convention for
the Prevention of Pollution from Ships; n.o.s. - Not Otherwise Specified; Nch - Chilean Norm;
NO(A)EC - No Observed (Adverse) Effect Concentration; NO(A)EL - No Observed (Adverse) Effect
Level; NOELR - No Observable Effect Loading Rate; NOM - Official Mexican Norm; NTP - National
Toxicology Program; NZIoC - New Zealand Inventory of Chemicals; OECD - Organization for
Economic Co-operation and Development; OPPTS - Office of Chemical Safety and Pollution
Prevention; PBT - Persistent, Bioaccumulative and Toxic substance; PICCS - Philippines Inventory of
Chemicals and Chemical Substances; (Q)SAR - (Quantitative) Structure Activity Relationship; REACH
- Regulation (EC) No 1907/2006 of the European Parliament and of the Council concerning the
Registration, Evaluation, Authorisation and Restriction of Chemicals; SADT - Self-Accelerating
Decomposition Temperature; SDS - Safety Data Sheet; TCSI - Taiwan Chemical Substance Inventory;
TDG - Transportation of Dangerous Goods; TSCA - Toxic Substances Control Act (United States); UN
- United Nations; UNRTDG - United Nations Recommendations on the Transport of Dangerous
Goods; vPvB - Very Persistent and Very Bioaccumulative; WHMIS - Workplace Hazardous Materials
Information System
DOW CHEMICAL PACIFIC (SINGAPORE) PRIVATE LIMITED urges each customer or recipient of
this (M)SDS to study it carefully and consult appropriate expertise, as necessary or appropriate, to
become aware of and understand the data contained in this (M)SDS and any hazards associated with
the product. The information herein is provided in good faith and believed to be accurate as of the
effective date shown above. However, no warranty, express or implied, is given. Regulatory
requirements are subject to change and may differ between various locations. It is the buyer's/user's
responsibility to ensure that his activities comply with all federal, state, provincial or local laws. The
information presented here pertains only to the product as shipped. Since conditions for use of the
product are not under the control of the manufacturer, it is the buyer's/user's duty to determine the
conditions necessary for the safe use of this product. Due to the proliferation of sources for
information such as manufacturer-specific (M)SDSs, we are not and cannot be responsible for
(M)SDSs obtained from any source other than ourselves. If you have obtained an (M)SDS from
another source or if you are not sure that the (M)SDS you have is current, please contact us for the
most current version.
SG
Page 11 of 12
Product name: XIAMETER™ AFE-0700 Antifoam Emulsion Issue Date: 03/14/2018
Page 12 of 12