Professional Documents
Culture Documents
The DDBC120-DALI is designed for cost-effective control of DALI high frequency fluorescent ballasts, providing a
full universe of 64 DALI address & communication to Philips Dynalite DALI user interfaces. Direct DALI to DyNet
mapping means that the DALI-imposed limits, such as the maximum of 16 groups, are seamlessly overcome allowing
for a fully scalable network solution. This leverages the advantages of a true DALI network whilst still allowing and
the full function set of DyNet. This device is DIN-rail mountable, designed to be installed in a switchboard, that is
supplying power to the controlled lighting circuit. The DDBC120-DALI contains an integral DALI bus power supply,
removing the need for the provision of a separate external supply which reduces switchboard wiring complexities.
Supply Terminals
Line, Neutral, Earth
1 x 4mm2 max conductor size
load compatibility DALI high frequency fluorescent ballasts DALI Emergency fixtures
DALI electronic low-voltage transformers Philips Dynalite DALI UI devices
DALI LED fixtures
DDBC120-DALI
DALI MultiMaster Controller
105
IN OUT
Load Power
Switch LOOP LOOP
DA -
DALI DA +
Supply: L
100-240V
59
0.25A N
1 Phase E
SHIELD
GND
AUX
D+
D-
+12
94.5
DyNet
69
RS485 46
75
51
38
Specifications subject to change without notice. © WMGD Pty Ltd Trading as Philips
Dynalite. Unit 6, 691 Gardeners Road Mascot 2020 Australia. ABN 33 097 246 921. All rights
reserved. Dynalite, DyNet and associated logos are the registered trademarks of Dynalite
WMGD Pty Ltd. Not to be reproduced without permission.