- Everyone must collect the answer sheet in .pdf before Friday 24:00 WIB at http://bit.ly/Tutorial07MS2110 - The tutorial will be conducted on Saturdays, 09:00 – 11:00 WIB - Your filename should be in format: K0X_NIM_Name.pdf with X is your class number. For instance: K01_13119500_Ganesha
1. The figure shows a state of stress of a point. By using
Mohr circle, determine the principal stress occured at that point.
2. Two forces P1 and P2, with magnitude of P1 = 15 kN
and P2 = 18 kN, are applied at the end of bar AB, which is welded to a cyllindrical member BD with radius of c = 20 mm as can be seen in the figure. Knowing that the distance from A to the axis of member BD is a = 50 mm and assuming that all stresses remain below the proportional limit of the material, please determine and draw the stress element of: (a) the normal and shear stresses at point H which is 60 mm from the end B, (b) the principal stresses at H, (c) the maximum shear stress at H.
3. The thin-walled pipe has an inner diameter of
0.6 in. and a thickness of 0.04 in. If it is subjected to an internal pressure of 750 psi and the axial tension and torsional loadings shown, determine the principal stress at a point on the surface of the pipe.