Professional Documents
Culture Documents
Part - A
Part Modeling & Assembly
Module 01 ― Introduction to the Pro/ENGINEER Wildfire Basic Modeling
Process
Module 02 ― Understanding Pro/ENGINEER Concepts
Module 03 ― Using the Pro/ENGINEER Interface
Module 04 ― Selecting and Editing
Module 05 ― Creating Sketcher Geometry
Module 06 ― Using Sketcher Tools
Module 07 ― Creating Sketches for Features
Module 08 ― Creating Datum Features: Planes and Axes
Module 09 ― Creating Extrudes, Revolves, and Ribs
Module 10 ― Creating Sweeps and Blends
Module 11 ― Creating Holes, Shells, and Draft
Module 12 ― Creating Rounds and Chamfers
Module 13 ― Copy and Mirror Tools
Module 14 ― Creating Patterns
Module 15 ― Measuring and Inspecting Models
Module 16 ― Assembling with Constraints
Module 17 ― Exploding Assemblies
Module 18 ― Using Layers
Module 19 ― Managing Design Intent
Module 20 ― Resolving Failures and Seeking Help
Table of Contents
Part - B
Sheetmetal Design
Module 01 ― Introduction to the Pro/ENGINEER Wildfire Sheetmetal Design
Process
Module 02 ― Sheetmetal Model Fundamentals
Module 03 ― Creating Primary Sheetmetal Wall Features
Module 04 ― Creating Sheetmetal Secondary Wall Features
Module 05 ― Modifying Sheetmetal Models
Module 06 ― Sheetmetal Bends and Setting Up the Sheetmetal Environment
Surface Modeling
Module 07 ― Surface Modeling Overview
Module 08 ― Advanced Selection
Module 09 ― Basic Surfacing Tools
Module 10 ― Helical Sweeps
Module 11 ― Creating and Editing Solids using Quilts
Detailing (Drawing)
Module 12 ― Introduction to Drawings
Module 13 ― Creating New Drawings
Module 14 ― Creating Drawing Views
Module 15 ― Adding Model Details to Drawings
Module 16 ― Adding Notes to Drawings
Module 17 ― Adding Tolerance Information
Module 18 ― Adding Draft Geometry and Symbols
Module 19 ― Using Layers in Drawings
Module 20 ― Using Report Information in Drawings
Module 21 ― Using Report Information in Drawings
Table of Contents