Professional Documents
Culture Documents
Solution Summary: Timbermatic 300 / 700; machine profiling in TMC 2.11 / 4.07->
Complaint or Symptom:
Problem or Situation:
Follow program loading instructions for 3G+ / 4G from T300:11 bulletin very carefully. If ignition is switched off
too early after module programming the system can't make automatic machine profiling after restarting.
Machine profiling can be done manually but in some cases default settings for the machine type must be done
first.
Solution:
Check functions of the machine and parameters in TMC and adjust if needed. Make machine profiling
manually.
Take backup copies of MAT parameters both in menu 0-3 (system settings to a memory card) and 0-4.
Timbermatic 300
http://dtac.deere.com/Solutions/English/68876.htm 2.5.2006