Professional Documents
Culture Documents
This page describes how to connect Enabler to Tokico LPG pumps (manuafactured in Japan). This
pump uses an RS-485 connection and a protocol called "SS LAN".
Note: Reliable communication with pumps using Tatsuno SS-LAN protocol requires Enabler
Card Firmware version of at least v2.71 build 01. If you have an earlier version, authorisation
and other important communications may be less reliable.
4. Multi-strand cable with 3 or more cores, to suit distance between PC and FDM - maximum 15
metres (45 feet). For example, CAT5 or CAT6 cable. Note that 2 cores is not enough as a
ground is needed as well.
5. Tools: wire stripper, soldering iron, solder, 3mm flat blade screwdriver.
6. Cabling to pumps if necessary. You can use the same shielded multi-core, multi-strand cable
as above.
Physical Connection
Connecting FDM to Enabler
Select which Enabler port (1-3) you will use. Strip the ends of the cable. Solder one end to the port
pins on the DB25 socket. Leave the other ends bare to connect to the FDM:
Make sure you connect the FDM RS-485 ground to the Enabler DB25 ground pins. This provides
protection to the Enabler card against surges, such as nearby lightning strikes. (If you have an old
revision 1 FDM, there is no ground pin)
Once completed, fit the clamp to the cables entering the DB25, and close the backshell on the DB25.
Label Pump
A A
B B
If all pumps are connected correctly the voltage from A to B should be between 1V and 4V DC. If it is
negative, you may have the A and B from The Enabler connected back to front.
Note: only the white and black wires (A and B) from the pump need to be connected to the FDM. The
red wire is ground. Try to swap A and B if no communication shown.
Configuring Enabler
Using the Web Applications > Configuration:
Ports: Set the port type as Tatsuno (SS-LAN) - not 'Tatsuno partyline - for the port
connected to the FDM.
3. Polling Address: Set the polling address = the address configured in the pump + 1.
Multipliers are configured in the "Pumps" webpage of the Enabler Web Configuration.
Tatsuno driver v2.7.4 or later is required for multipliers.