Professional Documents
Culture Documents
Symptoms
- Error messages occur during the utilization of Phoresis (e.g. error accessing files).
- Phoresis doesn’t work properly.
Causes
Resolution
Follow the steps below to customize Windows 7 when installing from a DVD or during the first power of a
PC with the preinstalled Operating System.
Applies to
This technical note addresses only technical matters related to application of our products. It does not address issues of health safety practices,
or any regulatory limitations that may apply, and does not constitute a recommendation of suitability for any purpose.
Page 1 of 5
WINDOWS 7 SETUP FOR PHORESIS INSTALLATION
ID: TN-2014-001 Date: January 8, 2014
To install and configure Windows 7 from a DVD, or for the first start of an Operating
System Windows 7 pre-loaded, you must follow these guidelines :
In the first step of installation, you must partition the hard drive before formatting it and run a “clean install
of Windows 7”.
Create a single user using the wizard that appears during the process by setting user name "Sebia" (this
becomes the only user and administrator on the computer).
Set the password "sebia" and a suggestion that does not contain the password.
Enter the product key to activate the license as soon as possible, if possible via the internet, or by calling
the toll number.
Find your country toll-free number at : https://www.microsoft.com/licensing/existing-customers/activation-
centers.aspx
Page 2 of 5
WINDOWS 7 SETUP FOR PHORESIS INSTALLATION
ID: TN-2014-001 Date: January 8, 2014
This operation is used to prevent the customer from having to confirm each time an application is open.
Page 3 of 5
WINDOWS 7 SETUP FOR PHORESIS INSTALLATION
ID: TN-2014-001 Date: January 8, 2014
STEP 6/9 : Set the display of file extensions in folder options (untick the highlighted box).
This setup is very important to facilitate the telephone support in the process of replacing files daily and total.
Page 4 of 5
WINDOWS 7 SETUP FOR PHORESIS INSTALLATION
ID: TN-2014-001 Date: January 8, 2014
It is preferable to manage the firewall with the system of exclusion rather than to turn it off completely.
If the computer needs to be registered in the laboratory network domain, each network user will have to
be configured with the full local “administration” rights. This is necessary to allow the software to run
correctly with the right access to every file.
Page 5 of 5