Professional Documents
Culture Documents
Mx3 Tool Registration Alarm 240
Mx3 Tool Registration Alarm 240
I don't think you need to reset the table, if that doesn't work I'll scan a couple
pages on re setting the table.
That's not a Yaskawa/Yasnac issue, that is a MTB (machine tool builder) error.
These errors are generated in the ladder software, on the machine side. If you
can't find it in a Matsuura maintenance or operator manual, it will have to be
found in the ladder diagram. If you don't have that or are unfamiliar with reading
them, call Methods and ask for their help.
Just in general for tool changers like that on a VMC, there will be parameters that
track the tool number in the spindle, the tool in the waiting pot (the next tool to
change) and which pot is empty. If you have a 20-tool magazine, for instance, one
pot or the spindle should be empty. If one parameter says the empty pot is 7, and
the parameter for Pot 7 says it has a tool in it, there is a conflict, and an error
will result. Clearing the error can't take place until revising the numbers in the
params so they don't conflict. This is an example, but gives you an idea of what
can occur in a tool table that would cause an error. Again, this machine behavior
is determined by the MTB, so is a general description, but can vary between brands.