Professional Documents
Culture Documents
1
Technical Specifications STREET
Note :
— All dimensions are under UNLADEN condition.
— Above information is subject to change without
any notice
2
Identification Data STREET
The Frame and Engine serial numbers are used to register the motorcycle. They are the unique
alpha-numeric codes to identify your particular vehicle from others of the same model and type.
3
Location of Parts (Avenger 150 Street) STREET
Speedometer
Grab Handle / Fuel Tank Cap
Pillion Back Rest.
Rear
Shock Absorber Brake Lever
Front Fork
Pillion
Foot Rest
Brake Lever
4
Steering cum Ignition Lock STREET
Warning : If you leave the P(Park) position Key : A common key is used for Ignition lock,
on for a longer time, the battery may get Steering lock, Fuel tank cap & Side cover lock.
discharged.
5
Fuel Tank Cap/ Fuel Tap STREET
6
Speedometer Details STREET
Speedometer display will work when both 6. Turn Signal Indicator (LH & RH) : It blinks
ignition switch & kill switch are in ‘ON’ position. when Turn signal switch is turned to L/R side.
1. Speedometer : The speedometer needle 7. Neutral Indicator Light : When
shows the speed of the vehicle in Km/Hr. transmission is in neutral, the neutral indicator
2. Odometer : It shows the total distance light will glow.
that the vehicle has covered. 8. Fuel Level Indicator : It shows approx
available fuel in fuel tank. Tank icon blinks
3. Trip Meter : It shows the distance when fuel level indicator is in red zone.
traveled since it was last reset to zero.
9. Low Battery Indicator : It indicates battery
4. Trip Meter Knob : Reset trip meter to needs charging.
zero by turning reset knob anticlockwise.
10. Hi Beam Indicator Light : When the H/L
5. Bajaj Logo : Bajaj Logo flying ‘B’. is on & the hi beam is selected then indicator
light will glow.
7
Speedometer Setting STREET
8
Control Switches STREET
9
Control Switches STREET
10
Removal & Fitment of Side Covers STREET
11
Battery / Tool Kit STREET
12
Daily Safety Checks STREET
13
How to Ride Your Bike STREET
14
How to Ride Your Bike STREET
15
How to Ride Your Bike STREET
CAUTION : Do not park on a soft or • Always keep the speed below the limits
steeply inclined surface or the motorcycle mentioned in the table.
may fall over. • Do not rev the engine excessively.
• Do not start moving or rev the engine
immediately after starting. Run the engine
for a minute at idle speed to give the oil a
chance to work up into the engine.
16
How to Ride Your Bike STREET
17
Safe Riding Tips STREET
Safe Riding Tips • Drive cautiously. Start early & reach your destination
• Always wear Helmet while riding. Your helmet should safely.
conform to appropriate Safety standards. • Always carry vehicle registration & insurance papers,
• Thoroughly read the and a valid driving licence with you.
instructions given in this manual • Avoid driving on loose sand or stones where vehicle
and follow them carefully. is likely to skid.
• Avoid unnecessary accessories • Properly wrap-up loose clothes while riding to avoid
for the safety of both rider and entangling in wheel or other objects on road.
other motorists. • Always concentrate on Safe riding.
• Get familiar with and follow
traffic rules & regulations in your states as well as Rainy Season Care :
general traffic signs. • It is suggested to customer to take appropriate care
• Familiaris yourself well with starting, acceleration and in area of high rainfall area. Appropriate surface
braking of the vehicle. preventive coat to avoid rusting on account of
• When applying the brakes, use both front & rear adverse atmospheric conditions.
brakes simultaneously. Applying only one brake may • Vehicle cleaning to be done with soft & clean wet
cause the rider to loose control. cloth to avoid scratches on painted parts.
• Riding at proper speed and avoiding unnecessary • Clean & lubricate all the important parts as detailed in
acceleration and braking are important not only for a periodic maintenance chart.
safety and low fuel consumption, but also for long life • Do not apply direct water jet on painted, electrical /
of the vehicle. electronic parts.
• During monsoon drive the vehicle more cautiously. • Do not obstruct engine cooling by adding mud
Remember vehicles skid more easily during light protection sheet from front.
showers.
18
Engine Oil STREET
19
Battery STREET
20
Wheels - Tyre STREET
Front 21 PSI
Avenger 150
Rear (Solo) 21 PSI
Street
Street Rear (with Pillion) 25 PSI
21
Periodic Maintenance Information STREET
0.8 to
0.9 mm
23
Periodic Maintenance Information STREET
Drive
Chain
Cleaning
Drive chain must be cleaned & lubricated as Method of O-ring Chain Lubrication
per periodic maintenance schedule. • Park vehicle perpendicular to the ground on level
Drive Chain (O-ring type) surface as mentioned in page no.18. Clean the
chain bye using lint free cloth (if excessive mud /
• ‘O’ rings must always be kept wet for best slush found approach Bajaj Service Center for
performance hence lubricate every 500km. proper cleaning)
• O-ring chain lubrication can easily be • Shake the can vigorously by holding vertically
done by owners using Bajaj ‘Chain Lube upright till the noise of steel ball inside heard
uniformly.
Spray Can’ available with Bajaj dealers,
• Hold spray can at the back of rear sprocket with
or equivalent. Ensure that the lubricant
extension tube mode at 5~10 cm.
does not damage the rubber ‘O’ rings.
• Rotate the wheel in reverse direction & spray the
lube on middle portion of the chain up to full
length of the chain.
24
Periodic Maintenance & Lubrication Chart STREET
RECOMMENDED FREQUENCY
Sr. Servicing 1st
Operation 2nd 3rd 4th 5th 6th 7th
No.
500 4500 9500 14500 19500 24500 29500 Remarks
Kms ~ ~ ~ ~ ~ ~ ~
750 5000 10000 15000 20000 25000 30000
1. Water wash & dry the vehicle Ensure to prevent water
completely entry in petrol
ü ü ü ü ü ü ü tank,Silencer & electrical
Parts. Use caustic free
detergent for washing.
4. Oil strainer CL CL CL CL CL
25
Periodic Maintenance & Lubrication Chart STREET
RECOMMENDED FREQUENCY
Sr. Servicing 2nd
Operation 1st 3rd 4th 5th 6th 7th
No. Remarks
500 4500 9500 14500 19500 24500 29500
Kms ~ ~ ~ ~ ~ ~ ~
750 5000 10000 15000 20000 25000 30000
9. Air filter cover ‘O’ ring CL,R CL CL CL R CL CL R
15. Valve tappet clearance C,A C,A C,A C,A C,A C,A C,A C,A
26
Periodic Maintenance & Lubrication Chart STREET
RECOMMENDED FREQUENCY
Sr. Servicing 2nd
Operation 1st 3rd 4th 5th 6th 7th
No. Remarks
500 4500 9500 14500 19500 24500 29500
Kms ~ ~ ~ ~ ~ ~ ~
750 5000 10000 15000 20000 25000 30000
Silencer tail pipe cleaning**
19. CL CL CL CL CL CL CL
Use recommended AP
20. Brake cam & brake pedal pivot pin CL,R C C,L,R C,L,R C,L,R C,L,R C,L,R C,L,R grease
27
Periodic Maintenance & Lubrication Chart STREET
RECOMMENDED FREQUENCY
Sr. Servicing 1st 2nd 4th
Operation 3rd 5th 6th 7th
No. Remarks
500 4500 9500 14500 19500 24500 29500
Kms ~ ~ ~ ~ ~ ~ ~
750 5000 10000 15000 20000 25000 30000
Handle bar control switches Use recommended WD40
27. C,CL C,CL C,CL C,CL C,CL C,CL C,CL C,CL
contacts cleaning spray
28. Steering play C,A C,A C,A C,A C,A C,A C,A C,A
Steering stem bearing*** & Cap C,CL, C,CL, C,CL, C,CL, Check & replace if
29. steering bearing (Plastic)**
L,R L,R L,R L,R damaged. Use HP Lithon
RR3 or equivalent grease
for lubrication
Idle speed / CO% C,A C,A C,A C,A C,A C,A C,A C,A
35.
28
Periodic Maintenance & Lubrication Chart STREET
RECOMMENDED FREQUENCY
Sr. Servicing 1st 2nd 3rd 4th 5th 6th 7th Remarks
No. Operation
500 4500 9500 14500 19500 24500 29500
Kms ~ ~ ~ ~ ~ ~ ~
750 5000 10000 15000 20000 25000 30000
** As applicable to model
*** More frequent cleaning may be required while driving in dusty environment.
Note : Periodic parts / lubricants as per periodic maintenance & chart are mandatory & the same is
chargeable to customer.
29
Non-Use Maintenance STREET
Non-use maintenance is necessary if a vehicle • Do not apply oil on front brake disc, to
remains off road for a longer duration (more than prevent rusting. If the front brake disc rusts
15 days**). The correct & careful non-use during storage, do not attempt to clean it
maintenance carried out before storing the with soap water. The rust will go off
vehicle will prevent the vehicle from rusting & automatically during first few application of
from such other non-operational damages like
fire hazards. brake.
• Clean the entire vehicle thoroughly. ** For Battery :
• Empty the fuel from the fuel tank & a. Remove battery & keep it on wooden plank,
carburettor float bowl (if fuel is left in for a in properly ventilated area.
longer time, the fuel will break and gummy b. Before taking the vehicle for use.
substance could clog the carburettor). • Get the battery recharged from the
• Remove the spark plug & put several drops Authorised Service Center / Battery Dealer.
of 2T oil into the cylinder. Crank the engine • Apply petroleum jelly on terminals.
over slowly a few times to coat cylinder wall (applicable to certain models).
with oil & install back spark plug.
• Set the vehicle on a box or a stand so that Preparation for regular use after storage :
both the wheels are raised off the ground. • Clean the vehicle
• Spray oil on all unpainted metal surfaces to • Make sure the spark plugs are fitted tightly.
prevent rusting. Avoid getting oil on rubber
• Fill the fuel tank with fuel.
parts or brake liners.
• Change the engine oil.
• Cover entire vehicle neatly. Make sure that
storage area is well ventilated & free from • Check all the points listed in the Daily Safety
any source of flames or spark. Checks section.
• Fill 10% excess air pressure in both wheels. • Check and inflate tyres to the proper tyre
pressure.
30