Professional Documents
Culture Documents
Electrical Tools
Screw Driver
Insp. Checks Pliers Cutter Pliers Nose Pliers Set Multimeter Current Meter
Note:
If above checks are OK then mark
If above check are NOK then mark
Conclusion :_____________________________________________________________________________________________________________________________________________________________
3 No hole in receptacle.
4 Cable properly connected with receptacle & receptacle seal present.
Conclusion :_______________________________________________________________________
_______________________ _______________________
Inspected By HSE
Inspection Frequency: Monthly Revision:00
1 Make sure there's no physical damage or crack on body, wire or push botton.
2 Make sure that tool is properly insulated and secured & no cut on wire.
5 Make sure there are no signs of overheating or looseness on receptacle and its pins
Conclusion :________________________________________________________________________________________
_______________________ _______________________
Inspected by HS&E
Inspection Frequency: Monthly Revision:00
1 Make sure there's no physical damage or crack on body, wire or push botton
2 Make sure that tool is properly insulated and secured & no cut on wire
5 Make sure there are no signs of overheating or looseness on receptacle and its pins
Conclusion :_______________________________________________________________________________________________
_______________________ _______________________
Inspected by HSE
Inspection Frequency: Monthly Revision:00
Inspection Frequency: Monthly Revision:00
2 Make sure that tool & cable is properly insulated and secured with no cut on cables.
4 Make sure cable is properly connected in receptacle & receptacle seal is present.
5 Make sure there are no signs of overheating or looseness on receptacle and its pins
Before use of the equipment make sure there's no loosness in cable terminal contact
6 (espcially welding holder and earthing)
Equipment must be in good working condition (with parts such as tyres, handle
7 ,switches, LED, regulator in working condition)
8 Make sure all holders have sleeves present and are in good condition.
9 Make sure earthing clamp is present
10
Conclusion: __________________________________________________________________________________________
_______________________ _______________________
Inspected by HSE
Revision :00
Inspection Frequency: Monthly
1 Make sure there's no physical damage or crack on body, wire or push botton.
5 Make sure there are no signs of overheating or looseness on receptacle and its pins
Conclusion: _______________________________________________________________________
_______________________ _______________________
Inspected by HSE
Inspection Frequency: Monthly Revision :00
1 Make sure the no physical damage or crack on body, wire or push botton.
8 Make sure ground cable is available and attached with the tool.
Conclusion: _______________________________________________________________________
_______________________ _______________________
Inspected by HSE
Inspection Frequency: Monthly Revision :00
The power distribution box has been connected with earthing device
2 (ELCB breaker)
Check ELCB live test with pressing test button( if breaker trip then its
5 OK if its doesnt trip then it is faulty.
8 Make sure all cable connections are proper fixed with cable lugs.
10
Conclusion:______________________________________________________________________________-
_______________________ _______________________
Inspected by HSE
Inspection Frequency: Monthly Revision: 00
7
8
9
10
Conclusion:_________________________________________________________________________
_______________________ _______________________
Inspected by HSE