Professional Documents
Culture Documents
MODULE 4
ACTIVITY
Direction: You were asked to read the Multitester where the range selector switch is
set to X100, read the resistance scale of the given items and using your note pad write
your answer or final reading of the resistance, if the reading is more than one thousand
divide the value by 1000 such that the final reading in ohms or kilo ohms as the case
maybe.
Black.
2. A component that can be tested for resistance that has primary and secondary
5. An electrical component that converts the energy to light is called Light bulb
POST-TEST:
Direction: Read and answer carefully. Choose the BEST answer from the given
choices.
C 1. The test probes of a multitester are red and black, the polarity of red is ______;
a. Negative b. Neutral c. Positive d. Proton
2. When you were asked about the polarity of the black test probe on a multitester,
A what is its polarity?
a. Negative b. Neutral c. Positive d. Proton
A 3. In the principle of resistance it is said that the length of conductors affect the
resistance “the longer the conductor (or the wire) the ____________”
a. Higher is the resistance c. There is no change in the resistance
b. Lower is the resistance d. None of the above
B 4. In a multitester this instrument is used for measuring the resistance.
a. Ammeter b. Ohmmeter c. Voltmeter d. Wattmeter
A 5. When is a circuit to be considered is “closed”, what does it mean?
a. There is continuity of current flow
b. There is no continuity of current flow
c. There is short in the line of the circuit
d. None of the above
B 6. The unit or the result of resistance is read as ________
a. Ampere b. Ohm c. Volt d. Watt
C 7. It is a device in electricity that converts the energy to light, the former design uses
tungsten as filament, lately is designed as LED.
a. Capacitor b. Diode c. Light bulb d. Resistor
A 8. This is a component that stores electrical energy in a circuit.
a. Capacitor b. Diode c. Light bulb d. Resistor
9. It is a semiconductor component acting as a one-way switch for current to flow in
B
one direction in the circuit, such component has a positive (+) and negative (-)
polarity when tested using the ohmmeter.
a. Capacitor b. Diode c. Light bulb d. Resistor
D 10. This is a component that is used in a circuit to reduce the current flow mostly with
colored band on the side which is decoded to determine the reading of this
component.
a. Capacitor b. Diode c. Light bulb d. Resistor