Professional Documents
Culture Documents
Service TEZ: Ceroifratiale
Service TEZ: Ceroifratiale
fi
SUBJECT : EQUIPMENT/FURNISHINGS
Rear bench-seat
Reinforcement of cushion attachment
A - EFFECT1VITY
AS 355 helicopters, all versions
B - REASON
To hold the cushions in place in caseof failure of the "VELCRO" strip attachment, during flights with the sliding
door open and without a passengeron the rear bench-seat.
C - DESCRIPTION
Addition of a strap on the rear of the brackrest, which passesthrough a loop on the seatcushion, and attaches
below the bench seat by an eye-end.
Widening of the "VELCRO" strips on the rear bench-seats.
Effect on interchangeability : Not affected
Effect on electrical balance : Not affected
D - COMPLIANCE
On production line From serial No. 5365
No 25.19
87-09 Page: 1/5
soc,e-reNATIONALE INDUSTRIELLE
DIVISION HEL1COPTERES - DIRECTION APRES-VENTE — B.P. 176 - 13723 - MARIGNANE (FRANCE)
SERVICE
(
WOTE : - Thisembodimentispurely indicative.
- Refer to the Aircraft Certificateof Conformity (or R.I.C. Aircraft Individual
InspectionRecord)to identify the actualmodificationstandard.
Retrofit action : By the operator
Spares : On new production
E - APPROVAL
AMS 350A07-1733 : Approved by the Veritas Office by Amendment on 18 April 1986.
F - MANPOWER
1 Mechanic : 3 hours approximately
G - MATERIAL - Cost-Availability
Lead times and prices will be given on the order acknowledgement form.
H - TOOLING - Cost-Availability
None.
J - REFERENCES
Refer to
No. 25.19
Page: 2
87-09
SERVICE
EE1171
2. - ACCOMPLISHMENT INSTRUCTIONS
A - PRELIMINARY STEPS
- Removethe four backrest and seatcushionsfrom the rear bench-seat.
- Removethe two panelsthat form the bench.
B - PROCEDURE
Figure 1
1 Modification of the RH and LH panels
View on B
- Removeand scrapthe fabric equipped with "velcro" strips
- Position RH and LH fabric sections
- Rework if necessary
- Bond the fabric to the RH and LH panelswith adhesive
- Mark and position the 8 fasteners 0
- Drill 16 3.3-rnmOholes
- Attach the fastenerswith 16 rivets 0
- Install the RH and LH panelson the rear bench.
C - IDENTIFICATION
Enter the embodiment of the modification in the aircraft documents.
The bench seatstructure assembly350A77-0182-00 becomes.02.
D - OPERATING INSTRUCTIONS
Not applicable.
No 25.19
87-09
Page: 3
SERVICE
TINTEd
VIEW ON B
cil
+ 4 50
tn
o
•-•—
7 4
38 1
L.H. PANEL SHOWN
VIEW ON D
R.H. PANEL OPP. HANDED
TOP OF CUSH1ON -
75
F
VIEW ON C 2 SEWING LINE
(backrest cushion ony
F.71 • •
I )( !X
VIEW ON F •
--=
,§ 6
5
5
FIGURE 1
No 25.19
Page: 4 87-09
SERVICE
TEXER
3.- MATER1AL INFORMATION
A - BASIC INFORMATION
The bill of material required for the application of this Service-Bulletin has been establishedfor
1 AS 355 helicopter
D PROCUREMENT CONDITIONS
from
AEROSPAT1ALE AISPA.410975F
Central Rechanges or TELEX
13725 MARIGNANE CEDEX (FRANCE) MAAV.A0G.410969F
IMPORTANT NOTE : ON THE PURCHASE ORDER PLEASE ALWAYS SPECIFY THE MODE OF TRANSPORT, THE
DESTINATION AND THE SERIALNUMBERS OF THE AIRCRAFT TO BE MODIFIED.
No. 25.19
J
87-09
Page: 5