Professional Documents
Culture Documents
Nozzle
78-10: NOZZLE
1. General
This section describes that portion of the exhaust system which collects the exhaust gases from
the turbine. This includes the exhaust nozzle.
The exhaust nozzle is a stainless steel duct connected to the aft flange of the aft bypass duct. The
exhaust nozzle is designed to bend the thrust vector 14° up with respect to engine centerline.
1
21 Dec 2016
CHAPTER 78-10: NOZZLE CIRRUS AIRPLANE MAINTENANCE MANUAL
MAINTENANCE PRACTICES VISION SF50
2. Maintenance Practices
A. Exhaust Nozzle
2
22 Oct 2020
CIRRUS AIRPLANE MAINTENANCE MANUAL CHAPTER 78-10: NOZZLE
VISION SF50 MAINTENANCE PRACTICES
• NOTE •
Install attaching parts loosely to check alignment of nozzle.
(b) Solvent clean bottom 180° of engine rear bypass duct and exhaust nozzle flange
area with isopropyl alcohol. (Refer to 20-30)
(c) Apply high temperature silicone sealant to bottom 180° of exhaust nozzle
flange.
• NOTE •
Do not add nut drag to torque.
(d) Slide exhaust nozzle through front side of aft engine bulkhead.
(e) Position exhaust nozzle and aft engine bulkhead to engine and secure with
bolts, washers, and nuts. Torque nuts 31 to 34 in-lb (3.5 to 3.8 Nm). (Refer to
20-60)
(f) After installing hardware, wipe excess sealant from inside of engine.
(g) Install grounding strap, washers, and nuts.
(h) Repair and paint aft pylon as required. (Refer to 51-20)
(i) Install engine pylon. (Refer to 54-50)
(j) Install engine nacelle. (Refer to 54-20)
3
22 Oct 2020
CHAPTER 78-10: NOZZLE CIRRUS AIRPLANE MAINTENANCE MANUAL
MAINTENANCE PRACTICES VISION SF50
3
4
7
3
2
6
5
3 4
3
3 5
3
4
8
LEGEND
1. Exhaust Nozzle
2. Aft Engine Bulkhead
3. Washer
4. Nut
5. Bolt
6. Bulkhead Clip
7. Screw
8. Ground Strap
DETAIL A
SF50_MM78_0362A
4
09 Jul 2018