Professional Documents
Culture Documents
1. Press and hold down the push button (2) for at least 5 ADR Adaptive Data Rate (on or off). X
seconds until the green LED responds. Data rate Current data rate of CMi4110 X
2. Via the LoRaWAN MCM mobile application. Start the (DR0-DR7).
mobile application, go to Apply mode and set the Tx interval The number of minutes between
Power mode to “Active”. Place the phone on the right each CMi4110 data transmission X X
side of the meter and press Apply settings. (1-1440).
Upon start-up, the green and the red LEDs will lighten up
for one second. The MCM will thereafter attempt to join the safety
LoRaWAN network. Each attempt is marked by a short blink of The warranty does not cover damage to the product caused
the green LED. Upon a successful join attempt, the green LED by usage in any other way than described in this manual.
will lighten up for 2 seconds. Elvaco AB can not be liable for personal injury or property
damage caused by usage in any other way than described in
When activated, CMi4110 will initially begin transmitting meter this manual.
data every minute in order to set the right data rate. After 10
minutes, the MCM will start using its configured Tx settings. Contact information
Configuration Elvaco AB Technical support:
CMi4110 settings can be configured via NFC by using the Phone: +46 300 434300
LoRaWAN MCM mobile application. Set Config source to E-mail: support @elvaco.com
select how you want to implement the new MCM settings: Online: www.elvaco.com