Professional Documents
Culture Documents
Telestart T91
1314649A_BA_T91.book Page 17 Wednesday, December 2, 2009 3:11 PM
02
1314649A_BA_T91.book Page 18 Wednesday, December 2, 2009 3:11 PM
03
1314649A_BA_T91.book Page 19 Wednesday, December 2, 2009 3:11 PM
D
GB
04
1314649A_BA_T91.book Page 20 Wednesday, December 2, 2009 3:11 PM
Optimum signal transmission is achieved out in the open or from a position higher
DD than the vehicle. In this case, the parking heater can be operated at a distance of
approx. 1,000 m from the vehicle.
GB When operating the transmitter, please hold it vertically pointing upward and do
not cover the upper side (see illustration).
If you determine from the lack of feedback that the operating signal has not
reached the vehicle, then you must change your position by a few metres. Recep-
tion quality is impaired accordingly in heavily built-up areas.
05
1314649A_BA_T91.book Page 21 Wednesday, December 2, 2009 3:11 PM
06
1314649A_BA_T91.book Page 24 Wednesday, December 2, 2009 3:11 PM
* not supported
07
1314649A_BA_T91.book Page 25 Wednesday, December 2, 2009 3:11 PM
08
1314649A_BA_T91.book Page 31 Wednesday, December 2, 2009 3:11 PM
Checking battery D
Press the ON or OFF button. or
Battery LED Action
GB
almost lights up for 2 seconds replace battery as
spent in orange soon as possible or
warm up transmit-
ter.
discharged flashes orange very Replace battery.
quickly for 5 seconds
drained no display Replace battery.
full lights up for 2 seconds Battery full
in green or red Attention:
With a
corresponding
range, the heater
could be activated
or deactivated.
09
1314649A_BA_T91.book Page 32 Wednesday, December 2, 2009 3:11 PM
Replacing battery
DD Also see page 21, "Teaching in Telestart transmitter
GB for Thermo Top E/C/P/V" and page 22, "Teaching in
Telestart transmitter Thermo Top with W-Bus con-
trol"
Note
Batteries from our products should be returned to
the place of purchase or its immediate vicinity fol-
lowing use. Return is free of charge. As an end user
you are legally obligated to return used batteries.
Caution!
Danger of explosion if the battery is replaced im-
properly! Dispose of used batteries as described in
the instructions! This product is subject to the Euro-
pean Directives 2002/96 EC and EN 50419. Dispos-
al instructions are included with the sample or the
operating instructions.
10
1314649A_BA_T91.book Page 226 Wednesday, December 2, 2009 3:11 PM
International: www.webasto.com
Autoplugin ES
Russia
Hotmail: mail@autoplugin.de
International: www.autoplugin.de