Professional Documents
Culture Documents
RPEL2-06 Dn 06 (D03) Qmax 60 l/min (16 GPM) • pmax 320 bar (4600 PSI)
Technical Features
›› Direct acting directional control valve with subplate mounting interface acc. to ISO 4401,
DIN 24340 (CETOP 03)
›› Cost-effective Lightline design with reduced solenoid dimensions
›› Five chamber valve design for high transmitted hydraulic power
›› Decreased dependence of function on fluid viscosity
›› Wide range of solenoid electrical terminas and supply voltage types for electromagnets
›› The coil, fastened to the core tube with a retaining nut, can be rotated by 360° to suit
the available space
›› Wide range of interchangeable spools
›› In the standard version, the valve housing is phosphated and steel parts zinc-coated
for 240 h protection in NSS acc. to ISO 9227.
›› Enhanced surface protection for mobile sector available (520 h in NSS, ISO 9227)
ISO 4401-03-02-0-05 Technical Data
4xM5-6Hx13 Valve size 06 (D03)
31,75 (1.25) Max. flow l/min (GPM) 60 (15.8)
0,75 (0.03)
Max. operating pressure at ports P, A, B bar (PSI) 320 (4640)
Max. operating pressure at port T bar (PSI) 210 (3045)
B G Fluid temperature range (NBR) °C (°F) -30 ... +80 (-22 ... +176)
Fluid temperature range (FPM) °C (°F) -20 ... +80 (-4 ... +176)
12,7 (0.50)
Ambient temperature range °C (°F) -30 ... +50 (-22 ... +122)
40,5 (1.59)
30,2 (1.18)
Operating limits - Power limit characteristics valid for 80% of nominal current.
DC AC
(5080) 350 1,4,3,7 6 5 8 2 350 1,4,3,5,7,6,2,8,9 11 10
Operating pressure p [bar (PSI)]
0 10 20 30 40 50 60 0 10 20 30 40 50 60
(2.6) (5.3) (8.0) (10.6) (13.2) (15.9) (2.6) (5.3) (8.0) (10.6) (13.2) (15.9)
Flow Q [l/min (GPM)] Flow Q [l/min (GPM)]
For operating limits under conditions and flow directions other than shown contact our technical support.
Page 1 www.argo-hytos.com
Subject to change · RPEL2-06_4036_1en_01/2021
Characteristics measured at ν = 32 mm2/s (156 SUS)
Z11,Z21,R11,R21,
2 2 3 3
X11,R32,X32
(363) 25 C11 5 5 5 6 3
(290) 20
6
6 H11 2 2 2 3 3
A51 2 2
5 Y11,Y51 2 2 2 2
(218) 15
4 Y41, 3 3 3 3
3
(145) 10 Z51,H51 2 3
2 R30 5 4 4 5
( 73) 5 1 C51 2 3 4
Z71 3 3
Z81 3 3
0 10 20 30 40 50 60 Z91 3 3 3
(2.6) (5.3) (8.0) (10.6) (13.2) (15.9) R31 2 3
Y91 3 3
Flow Q [l/min (GPM)]
Ordering Code
RPEL2-06 / -
- For directional valves with two solenoids, one solenoid must be de-energized before the other solenoid can be charged.
- For AC voltage supply use coils with connector type E5.
- For other solenoid voltage supply options see data sheet C_8007.
- The solenoid operated valves are delivered without connectors. For available connectors see data sheet K_8008.
- The orifice to the P port can be ordered separately, see data sheet SP_8010.
- Mounting bolts M5 x 45 DIN 912-10.9 or studs must be ordered separately. Tightening torque is 8.9+1 Nm (6.56+0.7 Ibf.ft).
- Besides the commonly used valve versions shown other special models are available. Contact our technical support
for their identification, feasibility and operating limits.
www.argo-hytos.com Page 2
Subject to change · RPEL2-06_4036_1en_01/2021
Spool Symbols
Y82
32
Y41
Y41
R21
E1 - EN 175301-803-A E3 - AMP Junior Timer E3A - AMP Junior Timer E5 - Connector EN 175301-803-A
E2 - E1 with quenching diode - radial direction - axil direction + integrated rectifier
E4 - E3 with quenching diode E4A - E3A with quenching diode
IP65 IP67 IP67 IP65
38,1 (1.50)
42 (1.65)
35(1.38)
29 (1.14)
37 (1.46)
37(1.46)
19 (0.75)
37 (1.46)
19(0.75)
19 (0.75)
37 (1.46)
19 (0.75)
19 (0.748)
37 (1.457)
37 (1.46)
19 (0.75)
The indicated IP protection level is only achieved if the connector is properly mounted.
No designation Designation M2
- standard - rubber boot protected
a a
65,5 (2.58) 78 (3.07)
In case of solenoid malfunction or power failure, the spool of the valve can be shifted by manual override as long as the pressure in port T does not
exceed 25 bar (363 PSI). For alternative manual overrides contact our technical support.
Page 3 www.argo-hytos.com
Subject to change · RPEL2-06_4036_1en_01/2021
Valve Dimension in millimeters (inches)
RPEL2-063x/xE1* 30
Valve with two solenoids 12,5 (0.49) 3+1Nm
Spool symbols
(2.2+0.7 lbf.ft)
Z11, C11, H11, Y11, H11, Y41 P
45,5 (1.79)
15,5 (0.61)
A
B
a b
T
65,5 ( 2.58) 68 (2.68) 65,5 (2.58)
199 (7,83)
12 (0.47)
9,5 (0.37)
~89,5 (3.52)
53,5 (2.11)
22,75 (0.89)
37,3 (1.47)
a b
5,3 (0.21)
RPEL2-062x/xE1*
RPEL2-062x/xE1*
www.argo-hytos.com Page 4
Subject to change · RPEL2-06_4036_1en_01/2021