Professional Documents
Culture Documents
1 Scope............................................................. 2
2 Conflicts and Deviations................................. 2
3 References..................................................... 2
4 Product Markings........................................... 2
5 Coatings......................................................... 3
1 Scope
2.1 Any conflicts between this specification and other applicable Saudi Aramco
Materials System Specifications (SAMSSs), Engineering Standards (SAESs),
Standard Drawings (SASDs), or industry standards, codes, and forms shall be
resolved in writing by the Company or Buyer Representative through the
Manager, Consulting Services Department of Saudi Aramco, Dhahran.
2.2 Direct all requests to deviate from this specification in writing to the Company
or Buyer Representative, who shall follow internal company procedure
SAEP-302 and forward such requests to the Manager, Consulting Services
Department of Saudi Aramco, Dhahran.
3 References
The selection of material and equipment, and the design, construction, maintenance, and
repair of equipment and facilities covered by this specification shall comply with the
latest edition of the references listed below, unless otherwise noted.
4 Product Markings
4.1 The pipe shall have all of the API marking specified in API SPEC 5L except the
symbol ERW shall be substituted for the symbol E.
4.2 The pipe shall be marked Saudi Aramco, followed by the destination, Purchase
Order number, and the Saudi Aramco Materials System (SAMS) Catalog
Page 2 of 3
Document Responsibility: Piping Standards Committee 01-SAMSS-031
Issue Date: 14 December 2009 Product Marking for Pipe
Next Planned Update: 15 December 2012 of Less than Six Inch Nominal Size
designated stock number. If there is no assigned SAMS stock number, the pipe
shall be marked with the item number of the order.
a) For pipe of nominal size 2-inch and above, the markings shall be on the
outside of the pipe and located approximately 300 mm from the end of
each joint. The area of pipe to be marked shall be clean and dry. The
marking shall be paint stenciled using a white alkyd enamel or equivalent
paint.
b) For pipe smaller than 2-inch nominal size, the marking shall be embossed
on metallic tags. The tag shall be attached to each bundle at one end.
5 Coatings
Pipe shall be supplied without mill coating unless specified otherwise in the Purchase
Order.
Revision Summary
14 December 2009 Revised the "Next Planned Update". Reaffirmed the contents of the document, and
reissued with no other changes.
Page 3 of 3