Professional Documents
Culture Documents
This guide is intended solely for the Samsung Electronics internal training and may contain
trade secret, industrial technology or privileged and confidential information otherwise
protected under applicable law including the Unfair Competition Prevention and Trade Secret
Protection Act. Any unauthorized dissemination, distribution, copying of use of the information
contained in this guide is strictly prohibited and subject to legal action.
All functionality, features, specifications and other product information provided in this
document including, but not limited to, the benefits, design, pricing, components, performance,
availability, and capabilities of the product are subject to change without notice or obligation.
Samsung reserves the right to make changes to this guide and the product described herein,
at anytime, without obligation on Samsung Electronics to provide notification of such change.
Countermeasure
- If there is no green tape on the left side of battery, attach the new tape for every disassembly (plus 1 SVC).
- Attach the protection tape on left side of the new battery in case of replacement the new battery.
Countermeasure
- Replace the old battery to the NEW one in case of detaching the old battery.
(i.e. Broken Bracket, Defective Battery)
- Check the battery status(Usage cycle and ASOC) with SW Capture tool before replacement.
Do the visual inspection and replace the battery in case of any damage or deform.
Countermeasure
- Attach a tape on the SIM socket in case of no tape on it. (Only for S6)
Caution
- Do NOT strongly push on the PCB area of Sub mic after repair receiver module.
Caution
- Be careful not to give any damage on the FPCB during handling the module.
Caution
- Use carefully Disassembly stick to detach the Back Glass or tape residue.
- Do NOT place on the Rear case edge part without tape.
- The film of Back glass backside can be damaged by fingernails.
- Avoid the Rear case edge part interference during attaching Back Glass.
Caution
- Inspect closely the appearance of Rear case and others,
such as distorted Rear case, Camera deco, NFC antenna before assembling Back glass.
Caution
- Do NOT push the Disassembly stick into LCD panel.
- Fold Cu Tape in the direction of 180º during detaching from LCD backside.
Caution
- Do visual inspection of LCD backside and Bracket outward appearance before assembling OCTA.
×
- Do NOT push the edge of LCD panel.
Caution
- Grip the coaxial cable with device and do visual check after assembly.
- The head of coaxial cable should not contact with C-clip on the Sub PBA.
OK NG
Caution
- When connecting LCD connector: Press Camera connector during connecting LCD connector.
- Check the acceleration sensor in *#0*# test mode after assembling the device.
If the image is not rotated, it is the acceleration sensor defect.
Caution
- Be careful not to interfere with outside of the PBA during handling the PBA.
7,250KRW 4101821300
(IMK)