Professional Documents
Culture Documents
shtml
Pin B17 (PRSNT2#/8K2) is tied up on a codec card to +12V through 8.2kOhm resistor. It is
possible for motherboard circuitry to detect presence of codec cards using this pin.
Pins indicated by asterisk (A6 ACZ_DET#, B12 SPDIF_OUT) are found only on SupremeFX II
Card; SupremeFX X-Fi has these pins unconnected (it has its own S/PDIF outputs).
Pins shown in gray (PE differential pairs, reset, wake, SMBus signals, and B7 GND) are not
connected on SupremeFX cards. While pin B7 is not used by codec cards (even not connected
to theirs ground plane), purpose of this is not unknown.
Codec reset / PE
1 +12V +12 V power PRSNT1#/RESET#
presence detect
Codec data
5 SMCLK SMBus clock SDATA_OUT
output
* Audio
6 SMDAT SMBus data ACZ_DET#
output detection
3.3 V auxillary
10 3.3Vaux +3.3V +3.3 V power
power
Signal for PE
PE Fundamental
11 WAKE# Link PERST#
reset
reactivation
Mechanical Key
* S/PDIF
12 SPDIF_OUT GND Ground
Output
Статус распиновки: +0 -0
На эту распиновку нет ни одного отзыва! Если вы знаете, правильная она или нет, - нажмите на
соответствующую кнопку ниже.
Эта распиновка
правильная с ошибками