You are on page 1of 1

MIRPUR UNIVERSITY OF SCIENCE & TECHNOLOGY (MUST) MIRPUR, AJK

Office of Controller of Examinations


Date Sheet for Terminal Examinations Faculty of Engineering Spring 2019
Electrical Engineering
Phone # 05827-961038

Date Groups & Time Subject Center


G-I (8:30-11:00) Signal and Systems(4th)
G-II(11:15-1:45) Engineering Management & Economics(6th)
Friday, July 19, 2019
Programming Fundamentals(2nd)
G-III(14:00-16:30)
…………………………
G-I (8:30-11:00) …………………………
G-II(11:15-1:45) Entrepreneurship(6th)

Saturday, July 20, 2019 Opto-Electronics(8th Electronics)


G-III(14:00-16:30) Power System Analysis(8th Power)
Navigation and Radar System(8th Telecommunication)

Kings International College Mirpur


G-I (8:30-11:00) Complex Variables & Transforms(4th)
Sunday, July 21, 2019 G-II(11:15-1:45) …………………………
G-III(14:00-16:30) Basic Civil Engineering(2nd)

G-I (8:30-11:00) Technical Report Writing(4th)

G-II(11:15-1:45) Instrumentation and Measurements(6th)


Monday, July 22, 2019 VLSI Design(8th Electronics)
G-III(14:00-16:30) Advanced Electrical Machine Design(8th Power)
RF and Microwave Engineering(8th Telecommunication)

G-I (8:30-11:00) …………………………


Tuesday, July 23, 2019 G-II(11:15-1:45) …………………………
G-III(14:00-16:30) Linear Algebra(2nd)
G-I (8:30-11:00) Basic Machanical Engineering(4th)
G-II(11:15-1:45) Electrical Machines (6th)

Wednesday, July 24, 2019 Embeded System Design(8th Electronics)

G-III(14:00-16:30) Power System Protection(8th Power)

Wave Propagation and Antennas(8th Telecommunication)

G-I (8:30-11:00) Electrical Network Analysis(4th)

G-II(11:15-1:45) Communication Systems (6th)


Friday, July 26, 2019
Basic Electronics(2nd)
G-III(14:00-16:30)
Integrated Electronics(8th Electronics)
Saturday, July 27, 2019 G-III(14:00-16:30) Communication Skills (2nd)
Sunday, July 28, 2019 G-III(14:00-16:30) Islamic Studies(2nd)

General Instructions:
1. The abbreviations represent the respective department as: Computer System Engineering (CSE), Electrical Power Technology
(EPT), Electrical Technology (ET), Mechanical Engineering (ME), etc.
2. The groups timing are in general for starting the paper(s). However, the ending time depends as per the requirement of
question paper(s).
3. The date sheet should be strictly followed by every department/institute.
4. The candidates are advised to intimate the clash of papers if any IMMEDIATELY to the Controller of Examinations.
5. The Candidates are directed to write their Roll Numbers carefully on the answer sheet only in the provided space.
6. Candidates are advised to make sure that they are not in possession of any helping paper, arms or any other material. The
candidate(s) found guilty of using unfair-means shall be charged under Examination Regulations.
7. Any candidate(s) or person(s) found involved in using unfair-means or misconduct/ keeping any type of electronic devices in
or around the Examination Hall shall be proceeded against under the Universities Malpractices (Eradication) Act, 1999.
8. ALL TYPES OF CELL PHONES/ELECTRIC DEVICES ARE NOT ALLOWED IN THE EXAMINATION HALL.

You might also like