Professional Documents
Culture Documents
Synonyms Z3-xx, Z4-xx, Z5-xx, Z10-xx, 4A-xx, ESIxx, HYPxx, Purmol xx,
RD-xx, ZEOX xx, XX-GDG, ZA-xx, ZX-xx, ZEOflair 1000
1.2. Relevant identified uses of the substance or mixture and uses advised against
Zeochem Adsorbents
Print Date 03.01.21 1/8
SDS-001 rev5
SECTION 2: Hazards identification
2.1. Classification of the substance or mixture
Classification according to Specific target organ toxicity (single exposure, inhalation), Cat. 3,
Regulation (EC) No. 1272/2008 H335
In accordance with Regulation (EC) No. 1272/2008 (CLP), the product does not need to be classified nor
labelled.
The product is non-dangerous according to GHS.
Note: The warning symbol has been voluntarily added, please see the supplemental information below.
Additional information For the full text of the phrases mentioned in this Section, see
Section 16.
2.2. Label elements
Precautionary statements P261: Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray.
P271: Use only outdoors or in a well-ventilated area.
P304 + P340: IF INHALED: Remove person to fresh air and keep
comfortable for breathing.
P312: Call a POISON CENTER/doctor if you feel unwell.
P403 + P233: Store in a well-ventilated place. Keep container
tightly closed.
P405: Store locked up.
P501: Dispose of contents/ container to an approved waste
disposal plant.
Supplemental information All potential hazards are caused by the products's property to
adsorb water. Dried product can dehydrate humid body parts
(eyes, mucus membranes, lungs) or irritate them by the heat
generated by the adsorption, the latter also applies to wetted or
sweaty skin. The product saturated with water has no dangerous
properties other than mechanical irritation by powder or small
particles.
Zeochem Adsorbents
Print Date 03.01.21 2/8
SDS-001 rev5
SECTION 3: Composition/information on ingredients
3.2. Mixtures
Components CLP Classification Product identifier
CAS-No.: 1318-02-1
Zeolite 75% - 100% EC-No.: 215-283-8; 930-915-9
For the full text of the phrases mentioned in this Section, see Section 16.
Hazardous impurities None known.
Eye contact Rinse thoroughly with plenty of water, also under the eyelids. If eye
irritation persists, consult a specialist.
Ingestion Clean mouth with water and drink afterwards plenty of water.
5.2. Special hazards arising from No data is available on the product itself.
the substance or mixture
Zeochem Adsorbents
Print Date 03.01.21 3/8
SDS-001 rev5
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
Advice for emergency Handle in accordance with good industrial hygiene and safety
responders practice.
6.3. Methods and material for Use mechanical handling equipment. After cleaning, flush away
containment and cleaning up traces with water.
7.2. Conditions for safe storage, Store in a dry place. Open aeration holes on container before
including any incompatibilities removing the lids to vent pressure or break vacuum. Product shelf
life is unlimited if kept dry in an airtight container. To prevent loss of
product effectiveness, minimize exposure time to ambient moisture
and ensure containers are tightly resealed after opening. Do not
return used or unused product to original container.
Zeochem Adsorbents
Print Date 03.01.21 4/8
SDS-001 rev5
Skin and body protection No special measures required.
10.5. Incompatible materials The activated product generates much heat in contact with water.
Zeochem Adsorbents
Print Date 03.01.21 5/8
SDS-001 rev5
SECTION 11: Toxicological information
11.1. Information on toxicological effects
Germ cell mutagenicity Animal testing did not show any mutagenic effects.
Reproductive toxicity Animal testing did not show any hazardous effects.
12.5. Results of PBT and vPvB This preparation contains no substance considered to be persistent,
assessment bioaccumulating nor toxic (PBT).
Zeochem Adsorbents
Print Date 03.01.21 6/8
SDS-001 rev5
12.6. Endocrine disrupting No information available.
properties
UN Model Regulations
Zeochem Adsorbents
Print Date 03.01.21 7/8
SDS-001 rev5
SECTION 15: Regulatory information
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
Regulatory Information In accordance with Regulation (EC) No. 1272/2008, the product
does not need to be classified nor labelled.
Disclaimer The information provided in this Safety Data Sheet is correct to the
best of our knowledge, information and belief at the date of its
publication. The information given is designed only as a guidance
for safe handling, use, processing, storage, transportation, disposal
and release and is not to be considered a warranty or quality
specification. The information relates only to the specific material
designated and may not be valid for such material used in
combination with any other materials or in any process, unless
specified in the text.
Zeochem Adsorbents
Print Date 03.01.21 8/8
SDS-001 rev5
Appendix 1 to SDS-001
⑤ Only Representative (OR) in Dr. Knoell Consult GmbH, Knoell NL B.V. REACH24H CONSULTING GROUP,
the EU according to Art. 8 www.knoell.com www.knoell.nl www.reach24h.com
Regulation (EC) No 1907/2006 Dynamostr. 19 Agro Business Park 75-83 Suite 1E, Paramount Ct., Corrig Road,
68165 Mannheim 6708 PV Wageningen Sandyford, Dublin 18, IRELAND
GERMANY THE NETHERLANDS Tel.: +353 1 8899 951
Tel.: +49 621 718 85 80 Tel.: +31 317 466 800 E-Mail: info@reach24h.com
E-Mail: info@knoell.com E-Mail: info@knoell.com
①②③④⑤ EN For translations, please consult page 2 SR Molimo pogledajte stranicu 2 za prevode
DE Die Übersetzungen finden sich auf Seite 2. JP 翻訳については、2ページを参照してください
FR Veuillez bien consulter page 2 pour les traductions CN 有关翻译,请参阅第2页
IT Per le traduzioni, consultare la pagina 2 BG За преводите, моля, вижте страница 2
ES Para las traducciones, consulte la página 2 KR 번역은 2 페이지를 참조하십시오."
NL Raadpleeg pagina 2 voor vertalingen
TH สำหรับกำรแปลโปรดปรึกษำหน้ำ 2"
CZ Překlady najdete na straně 2 MY Untuk terjemahan, sila rujuk halaman 2
TR Çeviriler 2. sayfada bulunabilir
V2.2 / 2021-01-03 1 of 2
Appendix 1 to SDS-001
V2.2 / 2021-01-03 2 of 2