The document contains four questions related to steel design:
1. Calculate the moment of inertia of a W360 x 44 beam with a plate attached to its upper flange.
2. Determine the minimum length of a column formed from two C 310 x 45 channels latticed together with equal moments of inertia about the principal axes.
3. Find the maximum load a connection of two plates joined by four 25mm diameter rivets can carry considering failure modes and allowable stresses.
4. Calculate the block shear strength of a single angle tension member connected to a gusset plate with 5/8" diameter bolts.
The document contains four questions related to steel design:
1. Calculate the moment of inertia of a W360 x 44 beam with a plate attached to its upper flange.
2. Determine the minimum length of a column formed from two C 310 x 45 channels latticed together with equal moments of inertia about the principal axes.
3. Find the maximum load a connection of two plates joined by four 25mm diameter rivets can carry considering failure modes and allowable stresses.
4. Calculate the block shear strength of a single angle tension member connected to a gusset plate with 5/8" diameter bolts.
The document contains four questions related to steel design:
1. Calculate the moment of inertia of a W360 x 44 beam with a plate attached to its upper flange.
2. Determine the minimum length of a column formed from two C 310 x 45 channels latticed together with equal moments of inertia about the principal axes.
3. Find the maximum load a connection of two plates joined by four 25mm diameter rivets can carry considering failure modes and allowable stresses.
4. Calculate the block shear strength of a single angle tension member connected to a gusset plate with 5/8" diameter bolts.
SORSOGON STATE UNIVERSITY four rivets 25 mm in diameter as shown. Find the maximum load T Sorsogon City that the connection can carry Engineering-Architecture Department considering all modes of failure. Allowable shearing stress for rivets = 70 MPa, allowable tearing stress of Final Exam in Principles of Steel Design plates = 100 MPa, and allowable bearing stress of rivets = 140 MPa. Series 1
Topics Covered: Properties of Section,
Analysis and design for axial tension, Analysis and design for axial compression:
1. The strength of a W360 x 44 rolled
steel beams is increased by attaching a plate to its upper flange. Determine the moment of inertia with respect to an axis which is parallel to the plate and passes through the centroid of the section. 4. Calculate the block shear strength (Refer to the steel table for the of the single angle tension member L relevant shape properties) 4 x 4 x 3/8 made from A36 steel which is connected to the gusset plate with 5/8 in. diameter bolts. The bolt spacing is 3 in. center-to-center and the edge distances are 1.5 in and 2.0 in as shown in the Figure below. (Express your answer in English units)
2. Two C 310 x 45 channels are latticed
together so that they have equal moments of inertia about the principal axes. Determine the minimum length of a column having this section, assuming pinned ends, E = 200 GPa and a proportional limit of 240 MPa.