Professional Documents
Culture Documents
4-Cycle
380-415 V Diesel
Tier 1 EPA-Comparable Standard Features
for Stationary Kohler Co. provides one-source responsibility for the generating
Emergency Applications system and accessories.
The generator set and its components are prototype-
Ratings Range tested, factory-built, and production-tested.
The generator set complies with ISO 8528-5, Class G3
Standby: kW 1580-1600
kVA 1975-2000 requirements for transient performance.
Prime: kW 1440-1452 The generator set accepts rated load in one step.
kVA 1800-1815 A standard one-year limited warranty covers all systems and
components. Two-, five-, and ten-year extended warranties are
also available.
Alternator Protection (standard with Decision-Maker® 550)
Electronic, Isochronous Governor
/' Oil Drain Extension
/ ""--
�. Operation and Installation Literature
Alternator Features:
o The pilot-excited, permanent magnet generator (PMG)
provides superior short-circuit capability.
o The brushless, rotating-field generator has broad
range reconnectability.
Other features:
• o Kohler designed controllers for guaranteed system
integration and remote communication. See Controllers
on page 3.
o An electronic, isochronous governor delivers precise
frequency regulation.
o Multiple circuit breaker configurations.
Generator Ratings
150 °C Rise 125°C Rise
Standby Rating Prime Rating
Alternator Voltage Ph Hz kW/kVA Amps kW/kVA Amps
RATINGS: All three-phase units are rated at 0.8 power factor. Standby Ratings: The standby rating is applicable to varying loads for the duration of a power outage. There
is no overload capability for this rating. Prime Power Ratings: At varying load, the number of generator set operating hours is unlimited. A 10% overload capacity is
available for one hour in twelve. Ratings are in accordance with ISO-8528-1 and ISO-3046-1. For limited running time and continuous ratings, consult the factory.Obtain
technical information bulletin (TIB-101) for rating guidelines and complete ratings definitions. GENERAL GUIDELINES FOR DERATION : Altitude: Derate 5.0 % per 500 m
(1640 ft) elevation above 1000m (3280 ft) up to maximum altitude of 4000m (13120 ft). Temperature: Derate 6.0 % per 10°C (18°F) temperature above 40°C (104°F) up to
maximum temperature of 60° C (140° F).
This document is not contractual - Kohler Co. reserves the right to modify any of the characteristics without notice, in a constant effort to improve the quality of its products.
GSD5-09006 (1800REOZM) 07/20
Alternator Specifications
Specifications Generator
NEMA MG1, IEEE, and ANSI standards compliance for
Type 4-Pole, Rotating-Field temperature rise and motor starting.
Exciter type Brushless, Permanent Magnet
Sustained short-circuit current of up to 300% of the
Generator
Voltage regulator rated current for up to 10 seconds.
Solid State, Volts/Hz
Insulation: NEMA MG1 Sustained short-circuit current enabling downstream
Material . . . . . . . . . . . . . . . . . . . Class H, Synthetic, circuit breakers to trip without collapsing the generator
Nonhygroscopic field.
Temperature rise . . . . . . . . . . . . 125°C Prime, 150°C Standby
Bearing: quantity, type 1, Sealed Self-ventilated and dripproof construction.
Coupling Flexible Disc
Amortisseur windings Full Superior voltage waveform from two-thirds pitch
Rotor balancing 150% 50Hz windings and skewed stator.
Voltage regulation, no-load to full-load
(with <0.5% drift due to temp Variation) 3-Phase Sensing, ±0.25% Brushless alternator with brushless pilot exciter for
One-step load acceptance 100% of Rating excellent load response.
Unbalanced load capability 100% of Rated Standby
Current
Application Data
Fuel Consumption 50 Hz
Diesel, Lph (gph) at % load Standby Rating
100% 410 (108.4)
75% 302 (79.9) NOTE: This drawing is provided for reference only and should not be used for planning
installation. Contact your local distributor for more detailed information.
50% 208 (55.0)
25% 116 (30.7)
This document is not contractual - Kohler Co. reserves the right to modify any of the characteristics without notice, in a constant effort to improve the quality of its products.