You are on page 1of 4

CONCLUSIONS

The purpose to do soil investigation to to determine the bearing capacity


of the soil, its settlement rate and the position of the water table. We had to
analysis the soil investigation report and find out the soil parameters. The
friction angle is 180. The cohesion value is 21kPa. The dry weight ,γdry is
14.809kN/m2. The saturated unit weight,γ satured is 28.663kN/m2. Moreover, we
had find out, the existing ground is formed by two(2) subsoil layers from
Reddish Yellow, Very stiff silty Clay to Dark Greyish,Hard, Silty Clay. The
ground water table is 11.20m below existing ground surface.

We had calculate the Qp ,Qu,Qs by using manual calculations. The value of


Qp is 185.22kN. The value of Qu is 725.61kN. The value of Qs is 540.39kN.
The data was analysis using the manual calculation.

By observing the ground condition and loading, pile foundation is deemed


the most suitable and economical system to support the proposed loading.
1000mm X 1000mm RC square pile foundation is deemed the most suitable
and economical to support the loading. The proposed 1000mm X 1000mm
RC square pile foundation with pile design capacity 725.61kN is deemed
acceptable subject to load test validation. By using Plaxis software, we had
designed and calculated the most suitable pile foundation. The extreme total
spacement is 5.47X10-3m. It is safe to do the pile foundation with this design.

You might also like