Professional Documents
Culture Documents
2
OPTIONAL
DETAILED PETAL
PIVOT AXLE PARTS
GLUE PETALS
TO LAYER OF
THICK CARD
PRINT ON
CARDSTOCK PETAL 1 – rover
and ramps.
OPTIONAL
3
DETAILED PETAL
PIVOT AXLE PARTS
PETAL 2
OPTIONAL
DETAILED PETAL
PIVOT AXLES
1
ROLL TIGHTLY
4 PRINT ON
CARDSTOCK
Pathfinder Mars Mission – Carl Sagan Memorial Science Station 1:12 scale
HGA HGA AXLE-2; ROLL AND INSERT
PRINT ON
INTO DISK AND AXLE-1
ROLL-INSERT IN DISK
CARDSTOCK
HGA BRACKETS
PETAL 1
ROLL
Bottom
Bottom
IMAGER
MAST
IMAGER HEAD
Bottom
PRINT ON
IMAGER BASE RING CARDSTOCK
PRINT ON PLAIN PAPER TO MAKE MORE EASILY ROLLED PARTS
USE AT LEAST FOUR LAYERS FOR STRENGTH Copyright 2010 John Jogerst
OPTIONAL Not for commercial use.
Roll axle (1) around toothpick or wire, then roll For personal or educational use only.
DETAILED PETAL
additional motor parts around axle to build up 3
PIVOT AXLES 2 required diameter.
2
3
METEOROLOGY MAST
ROLL TIGHTLY
1 ROLL TIGHTLY
LOW GAIN
ANTENNA
ROLL
HGA AXLE-1
HGA
ROLL-INSERT IN DISK
HGA AXLE-2
Pathfinder Mars Mission – Carl Sagan Memorial Science Station 1:12 scale
BASE
PETAL
FOLD UP
Single leaf hinges for instrument base section. Mark centerline of existing hinges FOLD DOWN LAMINATE
then remove – cut even with the edge of the frame. Fold hinges around a core of THICK CARD
BETWEEN
FOLD UP
heavy card and use tabs to attach to frame at the positions you marked.
EDGE
CORE
OF PATTERN
BASE
FOLD UP
Double leaf hinges for petals. Mark centerline of existing hinges then remove – cut even FOLD DOWN
with the edge of the petal. Fold hinge blades around cores of heavy card and use tabs CORE
LAMINATE
FOLD UP
THICK CARD
to attach to petal at the positions you marked. Check alignment with the hinges on PATTERNS BETWEEN FOLD UP
FOLD UP