Professional Documents
Culture Documents
[ Startside ] [ Linkside ] [ Planlagte prosjekter ] [ Flyfoto side ] [ Trådløs video ] [ Elektroni
kk ] [ Post ]
RC CDI Ignition
Link to forum on RC Universe
Features::
-As simple as possible
-Programmable advance control
-Use no exotic hard-to-find components
-Use a normal 4.8V RX battery
-Integrated spark test function, no signal generator is needed.
(makes 4 or 140 sparks/second without the need for a trigger input)
-Spark control can be separated from the voltage board
(to be used as a front end for a CDI without advance)
-Integrated strobe light
-May be extended with a failsafe/engine stop module. (not designed
yet)
The CDI is made by 2 modules; the voltage converter and the timing circuit.
It is best to make the timing circuit first, to have access to the test function when making
the voltage converter.
Voltage converter
Based on a free running oscillator, it has a very low part
count, and make 200-200 volts available for the coil.
It uses an ferrite core from an old computer as base for the
voltage converter.
A description of how to make the transformer is here.
Timing circuit
Based on a PIC16F84, running a code based ontransmics source 4.3
.
Coil
A lot of different coils is tested, and it is even possible to make a homemade coil.
This page has a full description of how to make a coil.
And on this page, you can see how to modify the original magneto coil.
Files
Source1.asm PIC16F84 ASM file for the PIC program
Source1.hex PIC16F84 HEX file for the PIC program
Map423.xls Excel file for making advance curves,
Power_schematics_v10.jpg Schematics, voltage converter NEW
Delay_schematics_v10.jpg Schematics, timing circuit NEW
Component layout NEW
Layout_PCB_v10.jpg
Part list:
Timing circuit
1 PIC16F84
1 resistor 240 ohm
2 resistors 470 ohm
3 resistors 10 K
1 green LED
1 red LED
2 capasitors 15pF
1 Hall effect device, Honeywell SS443A
Voltage converter
1 Transistor BD242B - Can be replaced with MJE2955 or BDW94C
1 Thyristor 2N6237 - Can be replaced with BT148
1 diode bridge
1 diode 1N4004
1 Resistor 500 ohm
2 Capasitors 4,7uF/16V and 0,47uF/250V
1 homemade toroid coil
1 Coil, Modelectric or homemade