Professional Documents
Culture Documents
By Lord VamPyr
AKA John Miller
I started this as I have not seen instructions for making Klingon Hand cuffs. I will try to include all steps
and information required to make these here in this manual.
Materials:
2 - 2"X4"X14" Wood.
Locking Latch
Tools:
3" or 3 1/2" hole Drill Bit.(I used 3 1/2")
Miter Saw or Table saw with a Miter Slide.
Common Screw driver.
Philips Screwdriver.
Sander.. ( You are going to need to sand the Wood smooth.)
Steps:
1. Cut 2 - 2 X 4 X 16"
2. Camp the together so you can safely cut out the 3 1/2 " holes.
5.
6. Cut Holes
7.
8. Sand everything.
9.
10. Paint one coat of Primer
11. Sand Everything again
12.
13. Paint again 2 coats of primer and add hardware.
14.
15. Paint everything.
16. Paint Klingon trefoil and apply with epoxy, and paint letters.
17.
22.5◦ Degrees 175.5◦ Degrees 7"
45◦ Degrees
1" 1
2"
4.5"
3" diameter 1.25" 3" diameter
2.2"
2"
1" 1"
1.25" 45◦ Degrees 45◦ Degrees
8"