Professional Documents
Culture Documents
Specification of
Single-jet dry type water meter
with LoRa Application
-1-
Ningbo Water Meter Co., Ltd.
Revised Record
-2-
Ningbo Water Meter Co., Ltd.
1- Application
SJ-SDC/ SJ-SDC-PLUS (LoRa application) is the smart water meter based on single jet mechanical dry type water
meter, the meter reading data transfer from Non-magnetic pulses counting to LoRa module to realize wireless
remote reading, real time flow status monitoring and consumption behavior analysis, the appearance is shown in
Figure 1
Figure 1
LORA Water
Meter
-3-
Ningbo Water Meter Co., Ltd.
3. - Key points
Transmission module and base meter is separately installed, easily exchanged. The power supply
battery is independently packaged and is convenient to replace.
A- Use the latest LoRa data transmission technology, network cover wide, signal is stable and reliable. C-
D- Based on the original base meter, it can directly install transmission module, only increase 28CM, the
E- The base meter adopt the independent function pointer, after installing the electronic module, it doesn’t
F- During the process of water meter with transmission module, it often happen the problem of repeated
Using two sensors and a special algorithm can ensure the accuracy of the count.
G- 26500+SPC1520 power combination technology, normally ER26500 battery is used for water meter
working with lower power consumption and charge for SPC1520. When LORA need to launch, SPC1520
can provide power supply with maximum peak current up to 2A, to ensure the stability of emission.
Performance Parameter
Working voltage 3.6V
Working power supply 26500+SPC1520
Data storage Data is stored for 10 years
Data collecting way Non-magnetic Transmission
Communication mode LORA
Working frequency Depend on customer requirement
Communication distance Base station signal coverage
Standby current < 40uA
Electromagnetic environment E1
-4-
Ningbo Water Meter Co., Ltd.
Table 1
mm (m3/h) (l/h) m3
SJ-SDC 50 31.25 80
15 3.125 2.5
SJ-SDC-PLUS 25 15.625 160
SJ-SDC 80 50 80
20 5 4
SJ-SDC-PLUS 40 25 160
Table 2
-5-
Ningbo Water Meter Co., Ltd.
Figure 3
3- Dimensions
-6-
Ningbo Water Meter Co., Ltd.
The battery can be replaced. Open the battery box seals and screws, remove the battery box, and replace
the new battery box as shown in Figure 6. If the meter has already been installed, no need to remove
Figure 4
4- Function achievement
Function Details
The water meter report in the daily cycle. Data
High frequency cycle reporting network settings. The minimum cycle reporting is
one-hour.
Setting the meter base that the electronic reading is synchronized with the
-7-
Ningbo Water Meter Co., Ltd.
Time calibration setting with the outside time. This function is realized in the
alarm.
Different start time on cycle reporting Each meter cycle has different start time.
Table 4
Note
-8-