SUPER/SUPER WHITE
Waterproofing Slurry
™ in-depth waterproofing and protection
| permanent active
| applied to pressure or non-pressure concrete
face
™ approved for potable water contact
™ grey or white
VANDEX SUPER and VANDEX SUPER WHITE are of a similar nature. Whereas
VANDEX SUPER is based on grey Portland cement VANDEX SUPER WHITE uses white
cement as binding agent. Alltechnical information of VANDEX SUPER apply also for
VANDEX SUPER WHITE except for colour, bulk density and setting time.
Product Description
VANDEX SUPER is @ surface-applied material which waterproofs and protects
cconerete in-depth,
It consists of grey or white Portland coment, specially treated quartz sand and @
compound of active chemicals. VANDEX SUPER is supplied in powder formin 25 kg
bags and needs only to be mixed with water prior to application.
Areas of Application
\VANDEX SUPER can be applied to all structurally sound concrete - new or old. itmay
be applied to either the pressure or non-pressure concrete face (i.e. with or against
water pressure),
\VANDEXSUPERmay be used in conjunction with VANDEX PREMIX (see separate data
sheet). Typical areas of application are:
basement retaining walls 1 swimmingpools
™ concretesiabs (loor/root/balcony, etc.) Ml sewage treatment plants
1B constructionjoints channels
water retaining structures bridges, ete.
Properties
‘When VANDEX SUPERIs appliedto a concrete surface the active chemicalscombine
withthe free lime and moisture present inthe cepillary tract, toform insoluble crystalline
‘complexes. These crystals block the capillaries and minor shrinkage cracks in the
concrete to prevent any further water ingress (even under pressure). However, the
\Vandex layer willstill allow the passage of water vapour through the structure (.¢, the
concrete will stil be able to breathe”). In addition to waterproofing the structure,
VANDEX SUPER protects concrete againstsea water, waste water, aggressive ground
water and certain chemical solutions. VANDEX SUPER is approved for use in contact
with potable water, and is therefore suitable for the treatment of water storage tanks,
reservoirs, watertowers, etc.
\VANDEX SUPER and VANDEX SUPER WHITE are not decorative materials,
Surface Preparation
All concrete to be treated with VAN DEX SUPER must be clean and have an ,open”
capillary system. Remove laitance, dirt, grease, etc. by means of high pressure water
Jetting, wet sandblasting or wire brushing. Faulty concrete in the form of eracks, honey:
‘combing, etc. must be chased out, treated with VANDEX SUPER and filled flush with
VANDEX UNI MORTAR 1. Surfaces must be carefully prewatered priortothe Vandex
application. The concrete surface must be damp but not wet.Mixing
VANDEX SUPERis mechanically mixed with clean waterto a consistency ofthick oil paint.
Approximate mixing ratio is 0.8 parts of water to 2.0 pars of powder (by volume)
Mix oniy as much material 2s can be used within 20 minutes and str mixture frequently.
Ifthe mixture star to set do not add more water, simply resi to restore workability
Application
Slurry consisteney.Apply VANDEXSUPERin one or two coats accordingto specification
by masonry brush or appropriate power spray equipment. When two coats are specified
apply the second coat whilst the first coat is stil .green”
Dry powder consistency (for horizontal surfaces only). The specified amount of
\VANDEX SUPERis distibutediin powder formthrougha sieve and rowelled intothe freshly
placed concrete once this has reached initial set.
Post treatment. The treated areas should be kept damp for a period of five days and
mustbe protected against direct sun, wind and frost, by covering with polythene sheeting,
damp hessian or similar.
Note: Do not apply VANDEX SUPER at temperatures below +5 °C.
\VANDEX SUPER cannot be used as an additive to concrete or plasters,
Consumption
Concrete surfaces to be backfilled. One coat of VANDEX SUPER at 0.75 kg/m?
followed by one coat of VANDEX PREMIX at 1.0 kg/m®. Brush or spray applied
Water retaining structures, internal concrete wall surfaces. Two coats of
VANDEX SUPER each at 0.75 kg/m*. Brush or spray applied
Conerete slabs. VANDEX SUPER at 1.2 kg/m* applied in one slurry coat to hardened
concrete or dry sprinkled and trowel applied to fresh concrete when this has reached intial
set
Construction joints. VANDEX SUPER at 1.5 kg/m? applied in slurry or dry powder
consistency immediately prior to placing the next lit/bay of concrete.
Blinding conerete. VANDEX SUPER at 1.2 kg/m? applied in slurry or dry powder
consistency immediately prior to placing the overlying concrete slab,
Packaging
25 kg PEined paper bags
Storage
‘When stored in a dry place in unopened, undamaged original packing, shelf life is 12
months.
Technical Data
VANDEX SUPER VANDEX SUPER WHITE
Aggregate state powder powder
Colour cement grey white
Bulk density approx. 1.25 kg/t approx. 1.20 kg/I
Settingtime 60 minutes 120-180 minutes
[Al cata are averages of several tats und Iaboratory conciions. In practice, simatic varatons such as
temperature, humicity, and porosity of substrate may affoct tose values,
Healthand Safety
VANDEX SUPER / SUPER WHITE contains cement,
Irritating to eyes and skin, VANDEX SUPER (grey) may cause sensitization by skincontact,
Keep outof reach of children. Avoid contact with skin and eyes. Incase of contact with eyes,
rinse immediately with plenty of water and seek medical advice. Wear suitable gloves,
For further information please refer to Material Safety Data Sheet.
‘hertmatoncnd en etandeno erg exec snteesoeurnowasge Woes hve maha parrcesroelasucesdovone a ceursaex rend
{atamuctbttennocoaircon eaten faa tooo on} aves Wie cea cs ih
landex
SHE! CONCRETE PROTECTION AND WATERPROOFING
HEADOFFCEAND NTERNATIONAL SALES ‘PRODUCTIONANDLOCAL SALES: LocaL sas:
VANOEXINTERNATONALLTO \ANOEXISOLCRWITEL-GESELLSCHAFT DH ‘VANDEKURLTO
O.SeKCH4St Sochumiwaetnd Past 05021457 Sewarerbeerany POBox, ule SereyGueeWOUMesngzom
Phone 060533 F528 807 rove aaeistes 0 raced OHS '580 ‘Prone 08702 ana, Fa T0274
Emekino@rntexcon www arcecon far igrantence ww anger Ematmogarencok wewvaniorcouk