wa
international Standard
‘Seat onal onGaniZAT/08 FOR ET ATOAAOVZAT/Ove MEXETV APORHAR OF ARFALAR NO CTANEATTVALinOO EAN ATION ITERNATIONALE OF RORWALSATION
ee aN SAN TERNATIONAL OE NORMALISATION
7 Welds in steel — Calibration block No. 2 for ultrasonic
\ examination of welds .
‘Soudures sur acier — Bloc d'etalonnage 1? 2 pour examen par ulresons des soudures
First edition — 1985-09-15
a
Y
sg UDC 620,179.16 : 53.089.6 : 627.791.083, Ref. No. 'SO 7983-1985 (E)
B Descriptors: seis, walking, welded ris, vets, utrasanic tens, calration, reference atmale, dimensions
8
Price bayed om 6 pages
SIr
€
INTERNATIONAL STANDARD
$80 7963-1985 (E)
i
Welds in steel — Calibration block No. 2 for ultrasonic
examination of welds
0 Introduction
‘This eaibration block differs in size and shape from the block
deserined in iSO 2400.
Iris very much smaller and theretore lighter, and its geometry is,
much simpi
Jpsdoes not offer as much scope as the larger block; in particular
fis not meant to check on ultrasonic flaw detector completely
Its easy handling, however, makes it possible, during practical
‘examination, to check simply, trom time to time, the setting of
the time base and the sensitivity of the ultrasonic equipment.
‘Moreover, itis suited to checking tne beam: angla and the probe
index of miniature shear wave probes.
1 Scope and field of application
‘This International Standard lays down the dimensions, type of
steel and diracivaa for tho use of block No. 2 for the ealbration
of ultrasonic equlament for the examination of welds in stee!.
2 References
180 488, Surface roughness — Parameters, their values end
‘general rotes for specifying requirements.
180 2400, Welds in steal = Reference block forthe calibration
‘of equioment for ultrasonic exanvination.
1S0 2604/4, Steel products for pressure purposes ~ Queity
requirements ~ Part 4: Plates,”
3 Dimensions
‘The dimensions of the block, in milimetres, are given in
figure s.
‘The tolerances are £0,1 mm, except on the length of the
engraved scale where itis 0,5 mm.
NoTes eee :
1 The thickness of the biock can be greater (see te anna.
2 In figure 1, Ry indicates the average roughness. Ryis not very ait
avert trom Ry Both ae Gelined in 180 468
At present atthe etage of dat Revision of (SO 2604/6-1978.1
4 Material
“Tne calibration block is made of steel of composition cor-
responding to P 18 of ISO 2604/4,
5 Preparation
‘The calibration block shall be homogeneous and free fram