the countries have a high reputation in provenance (country of orgin ) quality of production type N/A manufacturer N/A rated power watt (150-170) normal voltage V 120-270 v normal frequency Hz 50 Hz operating tempreture rang ˚C - 40 ˚C up to +65 ˚C power consumation w N/A power factor cos phi > 0.9 electrical protection (IEC) Class II compliance certificate CE , UL body Die-cast aluminium construction norms in compliance with EN 60598-1 , EN 60598-2-4 at an ambient temperature of + 35 ˚C ENEC approval : and the endurance test at+ 45 ˚C ingress protection IP66 protection degree against external impacts IK09 10 kv common mode & 6kv differential over voltage protection / surge protection ( IEC) kv mode LED Modules specification LED Modules brand N/A coloure temperature kelvin (k) 4000k luminaire efficacy lm/w >130 lm/w luminaire output flux lm N/A coloure rendering index (CRI) Ra > 80 % integrated NTC for over temperature over tempreture protection protection Evaluated at Ta = 35 ˚C L85* > maintained average luminous flux 100,000 hours luminaire and led module lifetime L80B10=100,000 h LIFETIME OF THE LEDS @ TQ 35 C ALL 100,000h-L90 configurations coloure consistency and maintenance at the time within a 5 step MacAdam ellipse the system is put into operation coloure consistency of the light source or within a 6 step MacAdam ellipse luminaire over the luminaire the upward light output ratio ULOR of light pollution the luminaire shall be %0 glare protection shield class of minimum G4 or higher photo biological safety for the LEDs Yes/No IEC 62471 a compliance all components of the lighting system shall have the following : marks of mark of conformity conformity : CE , ENEC (European norm Electromechanical certification ) the failure rate of the control gear . life time of control gear Shall be < 0.1 % per 1.000 hours. After 100.000 hours be < 10 % the warranty and /or service agreement period shall cover a tow year replacement of defective light sources ( including decrease of lumens below specification levels) , control gear and the warranty and /or service agreement shall /or luminaire at no coast . include : Compelete replacement of batches of luminaires in case more than 10 % of the units in the batch are defective . luminaire defective because of vandalism , accidents , or due to adverse weather effects , lamps and the warranty should exclude the following cases : luminaires operated under abnormal condition ( e.g. used with the wrong line voltage ) the availibility of spare parst shall be guaranteed for a period of ten years . The light source ( lamp or led module ) The luminaire reparability and availibilty of spare and auxiliaries must be easily parts accessible and replaceable on site . Repaire shall be accomplishable with standard , widely accessible tools should be in easy step by using the Access to optics and cable box quick reiease clip in stainless steel , without using additional tools . Glass Extra - cler tempered glass The luminaire should be equipped whith safety protection at the device's opening . a knife switch to interrupt the power supply at the device's opening . cable plate complete with easily replaceable electronic unit " plug and play " anti-inversion Yes / No system replacement of the entire LED module including Yes the upper cover pressure compensation filter in Teflon Yes / No To prevent accidental closure of the cover during assembly and maintenance , the device should Yes be equipped with an automatic anti-closing mecanism The power supply cable accesses the device a PG 16 cable gland(IP68) through Luminaire should be equipped with SPD type 1 IEC61547 bottom of the masts should be equiped with SPD IEC61548 type 2 Distribution cabinets should be equipped with IEC61549 SPD type 3 Power Density indicator (PDI) for Maleek Yes Mahmoud ring road case 1* Power Density indicator (PDI) for Maleek Yes Mahmoud ring road case 2* Power Density indicator (PDI) for Tasluja main Yes road light pollution (ULOR) Glare protection ( disability and discomfort glare )