Form 16847, 4-85
C111 REMOTE INDICATOR
OPERATING INSTRUCTIONS
Key Functions
The operator may use either key to select the desired display available from the remote
indicator.
1 | ~ Byppressing the “DOWN” key, the operator may step down thru the
displays as illustrated on the face of the remote.
4 | — Byppressing the “UP” key, the operator may step up thru the illustrated
displays.
The CRT will also change to correspond with the remote display.
Since there are no prompting instructions displayed on the remote, the CRT may still be
used as a guide in learning when to step “UP” or when to step “DOWN”. NOTE: If the
Prompting on the CRT is ignored, the instructions at the bottom of the CRT will not
change until that step is completed. However, the operator may still use either remote
key to change the displays.
Display Functions
‘The C111 Remote Indicator uti
adjustment display.
‘es both a bar graph adjustment display, and a digital
The bar graphs display the difference between the actual readings (compared to
tolerance) and the specifications. When one center green light is lit, the adjustment is
within the entered tolerance. When both center green lights are lit, the adjustment is
within % the entered tolerance.
OUT OF TOLERANCE
PREFERRED ADJUSTMENT
(WITHIN 4 ENTERED TOLERANCE)
ACCEPTABLE ADJUSTMENT
(WITHIN ENTERED TOLERANCE)
The digital adjustment displays are “LIVE” readings and NOT zero adjust. When making
alignment corrections using this display, adjust the vehicle until the display
EQUALS the specification.
NOTE: Each time a caster measurement is taken the remote will go blank.
To turn the remote back on simply press [4].