Professional Documents
Culture Documents
Parts Visual Check: Administration No
Parts Visual Check: Administration No
ADMINISTRATION No.
∼
Location :
Dealer Name :
Customer Name :
FOR EX2600-7
CONTENTS
INTRODUCTION ........................................................................................................ 1
【 NOTE 】
For any questions feel free to apply to your nearest dealer.
INTRODUCTION
For this location in the machine, check items are detailed on this check sheet.
-1-
INSPECTION PROCEDURE
1 Use the check sheet for the monthly (250 hours) maintenance.
2 In the check sheet, the locations of the machine are shown on the left page, and
check items on the right page. Fill in the check sheet during inspection.
3 Fill in the blanks on the monthly check sheet shown below during inspection using
the check sheet provided.
4 Report the inspection results by following the inspection procedure indicated on the
next page.
-2-
PRECAUTIONS FOR INSPECTION
Hydraulic hoses and lines should be inspected as set forth below. If any defect is found,
replace immediately. Any hose, line or other part that needs replacement should be
replaced only with Hitachi approved parts from an Hitachi authorized dealer.
CAUTION
Hoses and lines should be checked for leaks by using a piece of cardboard or other
material held against the hose or line to protect the hand. Do not use bare hands to
check for leaks since escaping fluid under pressure can penetrate the skin, causing
severe injury.
1 Check hydraulic hoses and lines, joints and screws for any damage, including kinks,
cracks, cuts or excess wear.
2 Check to insure that hydraulic hoses and lines do not rub against each other.
3 Check for missing or loose clamps and damaged or loose oil-cooler flange bolts.
4 Tighten, repair or replace any missing, loose or damaged hoses, lines, clamps and
oil-cooler flange bolts.
Never install bent or damaged hoses or lines.
5 Check hydraulic oil cooler for leaks, loose screws and any damage, including cracks,
cuts and excess wear, If any defect is found, replace immediately only with Hitachi
approved parts from an Hitachi authorized dealer.
Check for missing or loose clamps and damaged or loose oil-cooler flange bolts.
6 Check fuel lines for leaks, looseness or any damage, and repair or replace if
necessary.
7 Electrical cables, wires and wire harnesses should be inspected as set forth below.
If any defect is found, replace immediately. Any electrical cable, wire, wire harness
or other part that needs replacement should be replaced only with Hitachi approved
parts from an Hitachi authorized dealer.
8 Check the wires connecting the battery to the engine and the wires connecting the
engine to the ignition and emergency shut-off button.
9 Cable or wires that are loose, kinked, hardened or frayed should be tightened,
repaired or replaced prior to operation.
10 Cables or wires that have scratched or peeling insulation or coatings should be
replaced.
11 Loose or disconnected terminals should be tightened or replaced.
12 All electrical connections should be cleaned and tightened.
13 Missing or damaged terminal caps should be repaired or replaced.
14 At the beginning of every shift, check to make certain the engines can be stopped
from the driver's seat.
15 Clean machine daily, removing accumulations of oil, coal dust and other flammable
materials.
-3-
PRECAUTIONS IN USING THE PARTS VISUAL CHECK SHEET
CHECK SHEET
2 Should an inspection disclose any
defective part that needs
CHECK
replacement, purchase a genuine
Hitachi part from the dealer.
PARTS CATALOG
[Note]
The parts numbers for
machines manufactured after
this check sheet was revised
might have changed. Be sure
to check it either through the
parts catalog attached to the
machine or through the dealer.
Fig.B
Fig.C
-4- Sheet 01
PARTS VISUAL CHECK
A SPECIFICATIONS
Front D M Y
Front attachment attachment Capacity Date of Delivery
S/No. , ,
Boom m
Date
Loader front Arm m Hour meter of
of
inspection
Backhoe front Bucket m3 inspection
D M Y
hour , ,
C CONTENTS
Sheet 01
NOTES
CHECK SHEET No.1
PIPING SYSTEM
LOCATION
A FUEL PIPINGS
00
04 03
02
05
01
Sheet 02
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 01
PIPING SYSTEM
A FUEL PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 YA00049099 (00)
01 YA00052211 (20)
02 YA00052213 (02)
03 YA00049132 (04)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage b b
P/C Item a Connection b Crimp c Surface
04 4639391 (00)
05 YA00049131 (03)
COMMENT
Sheet 02
LOCATION
B FUEL COOLER PIPING
00
01 02 03
Sheet 03
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 02
PIPING SYSTEM
B FUEL COOLER PIPING
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 YA60049445 (64)
01 YA00052210 (54)
02 YA00052209 (53)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage b b
P/C Item a Connection b Crimp c Surface
03 YA60049444 (63)
COMMENT
Sheet 03
LOCATION
C SUCTION PIPINGS
00
03 02
04 01 05 06 07
Sheet 04
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 03
PIPING SYSTEM
C SUCTION PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
b
a a
Faulty Other
Item PART No. Crack Rubbed Comment
c clamp remarks
c
P/C Item a Connection b Crimp c Surface
00 4193871 (06)
01 YA00051594 (21)
02 YA00051595 (22)
03 4204186 (23)
04 4204186 (23)
05 4441963 (25)
06 4441961 (24)
07 4442830 (26)
COMMENT
Sheet 04
LOCATION
D TRANSMISSION COOLER PIPINGS (1)
00 01
Sheet 05
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 04
PIPING SYSTEM
D TRANSMISSION COOLER PIPINGS (1)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 YA60048807 (07)
01 YA60048808 (08)
COMMENT
Sheet 05
LOCATION
E TRANSMISSION COOLER PIPINGS (2)
03 01
04 06 05 02 00
Sheet 06
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 05
PIPING SYSTEM
E TRANSMISSION COOLER PIPINGS (2)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 4684745 (11)
01 4641112 (10)
02 YA00008490 (12)
03 4365395 (16)
04 4251907 (15)
05 4207388 (65)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c a
Faul Other
Item PART No. Crack Rubbed Comment
clampty remarks
Oil leakage b b
P/C Item a Connection b Crimp c Surface
06 4690164 (57)
COMMENT
Sheet 06
LOCATION
F DELIVERY PIPINGS
01 07
04 00 02 03 05 06
Sheet 07
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 06
PIPING SYSTEM
F DELIVERY PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
c c
a
Faulty Other
Item PART No. a b b Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 YA00055740 (00)
01 4671626 (00)
02 4612007 (04)
03 4441543 (08)
04 XV00003658 (02)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage b b
P/C Item a Connection b Crimp c Surface
05 4622750 (32)
06 4622750 (32)
07 4622750 (32)
COMMENT
Sheet 07
LOCATION
G DRAIN PIPINGS
00
00 01 02
02
03 04
01
09 08 07 06 05
Sheet 08
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 07
PIPING SYSTEM
G DRAIN PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage b b
P/C Item a Connection b Crimp c Surface
00 YA60053819 (35)
01 YA60053816 (34)
02 YA60053815 (33)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
03 4678497 (22)
04 4680278 (20)
05 4354655 (19)
06 4639926 (21)
07 XV00003682 (23)
08 4217389 (24)
09 XV00003681 (25)
COMMENT
Sheet 08
LOCATION
H FAN DRIVE PIPINGS
05 06 07
08
09
10
11
14 13 04 03 02 01 12 00
Sheet 09
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 08
PIPING SYSTEM
H FAN DRIVE PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c
a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
b b
Oil leakage
P/C Item a Connection b Crimp c Surface
00 4673494 (38)
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
01 4414656 (05)
02 YA60048930 (00)
03 4687691 (03)
04 XV00003878 (04)
05 4640837 (14)
06 4227025 (18)
07 XV00003677 (29)
08 XV00003676 (25)
09 4705873 (26)
10 4446905 (30)
a c a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage b b
P/C Item a Connection b Crimp c Surface
11 4685916 (22)
12 4304477 (27)
13 YA00007517 (30)
14 YA00007517 (30)
COMMENT
Sheet 09
LOCATION
I RETURN PIPINGS
02
07
04
08
01 09
05
00 06 10 11 03
Sheet 10
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 09
PIPING SYSTEM
I RETURN PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
b c b
Faul Other
Item PART No. Crack Rubbed Comment
clampty remarks
Oil leakage a a
P/C Item a Connection b Crimp c Surface
00 4067833 (21)
01 4067833 (21)
02 4067833 (21)
03 4067833 (21)
SATISFACTORY
UNSATISFACTORY
CORRECTED
b c b
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage a a
P/C Item a Connection b Crimp c Surface
04 4071214 (22)
05 4071214 (22)
06 4071214 (22)
SATISFACTORY
UNSATISFACTORY
CORRECTED
b c b
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage a a
P/C Item a Connection b Crimp c Surface
07 4071215 (23)
08 4071215 (23)
09 4071215 (23)
10 4071215 (23)
11 4071215 (23)
COMMENT
Sheet 10
LOCATION
J SWING PIPINGS
04
02
05
03
00 01
Sheet 11
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 10
PIPING SYSTEM
J SWING PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
c c
a
Faulty Other
Item PART No. a b b Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 4440424 (00)
01 4440424 (00)
02 4671800 (12)
03 4671800 (12)
04 4671801 (13)
05 4671801 (13)
COMMENT
Sheet 11
LOCATION
K TRAVEL PIPINGS (1)
02 00
03
01
Sheet 12
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 11
PIPING SYSTEM
K TRAVEL PIPINGS (1)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c
a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
b b
Oil leakage
P/C Item
a Connection b Crimp c Surface
00 4651806 (01)
01 YA00051569 (02)
02 4601145 (00)
03 YA00051570 (03)
COMMENT
Sheet 12
LOCATION
L TRAVEL PIPINGS (2)
02 03 09 11
00
01
08
10
04 07
05
06
Sheet 13
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 12
PIPING SYSTEM
L TRAVEL PIPINGS (2)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 4678995 (04)
01 4678995 (04)
02 4678995 (04)
03 4678995 (04)
SATISFACTORY
UNSATISFACTORY
CORRECTED
c c
a
Faulty Other
Item PART No. a b b Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
04 4673041 (00)
05 4673041 (00)
06 4678796 (05)
07 4678796 (05)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a b c b a Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
08 4435992 (14)
09 4435992 (14)
10 4712781 (17)
11 4712781 (17)
COMMENT
Sheet 13
LOCATION
M BACKHOE FRONT MAIN PIPINGS
00
04 03 02 01
Sheet 14
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 13
PIPING SYSTEM
M BACKHOE FRONT MAIN PIPINGS
SATISFACTORY
UNSATISFACTORY
CORRECTED
c c
a a
Faulty Other
Item PART No. b
Crack Rubbed Comment
b clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 4720135 (36)
SATISFACTORY
UNSATISFACTORY
CORRECTED
a c
a
Faulty Other
Item PART No. Crack Rubbed Comment
clamp remarks
b b
Oil leakage
P/C Item a Connection b Crimp c Surface
01 YA00001209 (04)
SATISFACTORY
UNSATISFACTORY
CORRECTED
c c
a
Faulty Other
Item PART No. a b b
Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
02 4011638 (03)
03 4011638 (03)
04 4011638 (03)
COMMENT
Sheet 14
LOCATION
N BACKHOE FRONT PIPINGS (2)
08
09
03 06
07
04
05
00
01
02
Sheet 15
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 14
PIPING SYSTEM
N BACKHOE FRONT PIPINGS (2)
SATISFACTORY
UNSATISFACTORY
CORRECTED
c c
Faulty Other
Item PART No. a b b a Crack Rubbed Comment
clamp remarks
Oil leakage
P/C Item a Connection b Crimp c Surface
00 4720039 (09)
01 YA00002206 (08)
02 YA00002206 (08)
03 YA00002162 (02)
04 YA00002162 (02)
05 4720029 (01)
06 4720028 (00)
07 4720037 (07)
08 4720028 (00)
09 4720037 (07)
COMMENT
Sheet 15
NOTES
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
CHECK SHEET No.2
ELECTRIC PARTS
LOCATION
A AROUND ENGINE REAR SIDE
01 02 03 04 05 06
11 12 13 14 15 16 17 18
07 08 09 10
23 22 21 20 19
Sheet 16
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 01
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
A AROUND ENGINE REAR SIDE CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
08 +++++++(++)
09 +++++++(++)
10 +++++++(++)
11 +++++++(++)
12 +++++++(++)
13 +++++++(++)
14 +++++++(++)
15 +++++++(++)
16 +++++++(++)
17 +++++++(++)
18 +++++++(++)
19 +++++++(++)
20 +++++++(++)
21 +++++++(++)
22 +++++++(++)
23 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 16
LOCATION
B AROUND REAR SIDE OF ENGINE
01 02 03 04 05 06
07
08
09
Sheet 17
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 02
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
B AROUND REAR SIDE OF ENGINE CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
08 +++++++(++)
09 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 17
LOCATION
C MAINFRAME UNDER THE RADIATOR
01
02
03
04 05 06 07 08 09 10 11 12 13 14 15 16 17
01
02
03
18
19
Sheet 18
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 03
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
C MAINFRAME UNDER THE RADIATOR CORRECTED
02 +++++++(++)
03 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
08 +++++++(++)
09 +++++++(++)
10 +++++++(++)
11 +++++++(++)
12 +++++++(++)
13 +++++++(++)
14 +++++++(++)
15 +++++++(++)
16 +++++++(++)
17 +++++++(++)
18 +++++++(++)
19 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
Sheet 18
LOCATION
E AROUND UNDER THE FUEL TANK
01 02 03 04 05 06 07 08 09 10
Sheet 19
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 04
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
E AROUND UNDER THE FUEL TANK CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
08 +++++++(++)
09 +++++++(++)
10 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 19
LOCATION
F AROUND STARTER MOTOR
01 05
02 06
03
07
04
Sheet 20
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 05
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
F AROUND STARTER MOTOR CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 20
LOCATION
G AROUND ALTERNATOR
04 05
01
02
03
06
Sheet 21
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 06
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
G AROUND ALTERNATOR CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 21
LOCATION
H AROUND BATTERY
07
01 08
02
09
03
04
05
10
06
11
22 23 24 25 26 27 28 29 30 31
12
16
13 17
19
14
20
15 21
18
37 36
01 35 34 33 32
Sheet 22
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 07
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
H AROUND BATTERY CORRECTED
COMMENT
Sheet 22
LOCATION
I UNDER UREA TANK
01 02 01
03 01
04 01
05 01
06 01
07 01 09
08 01 10
01 01
11 01
12 01
13
Sheet 23
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 08
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
I UNDER UREA TANK CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
08 +++++++(++)
09 +++++++(++)
10 +++++++(++)
11 +++++++(++)
12 +++++++(++)
13 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 23
LOCATION
J PUMP LOWER FRAME SIDE
03 04 05 06 07 08 09 10 11 12
01
02
Sheet 24
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 09
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
J PUMP LOWER FRAME SIDE CORRECTED
02 +++++++(++)
03 +++++++(++)
04 +++++++(++)
05 +++++++(++)
06 +++++++(++)
07 +++++++(++)
08 +++++++(++)
09 +++++++(++)
10 +++++++(++)
11 +++++++(++)
12 +++++++(++)
Additional harness※
※ Check harness added by customer or dealer for each item.
COMMENT
Sheet 24
LOCATION
K Harness joint after cab
01 07
08
02
09
03
10
04
11
05
12
06
13
18 19 20 21 22 23 24 25
14
15
16
17
28 27 26
Sheet 25
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 10
ELECTRIC PARTS
SATISFACTORY
UNSATISFACTORY
K Harness joint after cab CORRECTED
COMMENT
Sheet 25
NOTES
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
CHECK SHEET No.3
IMPORTANT CHECKS
LOCATION
A ENGINE STOP SWITCH
Sheet 26
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 01
IMPORTANT CHECKS
A ENGINE STOP SWITCH
SATISFACTORY
UNSATISFACTORY
CORRECTED
6 Turn on engine key switch ⓐ. Unable to start and crank the engine.
COMMENT
Sheet 26
LOCATION
B CLEANING THE MACHINE
For the safety of the machine and self, it is important to always keep the entire machine clean.
For this purpose, it is preferable to periodically clean the machine in particular, the battery compartment
and engine compartments shown below should be thoroughly cleaned.
01 Battery compartment
02 Engine compartment
Add. any field-installed equipment such as a generator set, light, compressor, air conditioner, etc. to the
above figure, and check fuel system hoses, electric wires, etc. for the sake of safety.
Sheet 27
PART VISUAL CHECK SHEET FOR EX1200-7
REPORT No. 02
IMPORTANT CHECKS
SATISFACTORY
UNSATISFACTORY
CORRECTED
01 Battery compartment
02 Engine compartment
SATISFACTORY
UNSATISFACTORY
CORRECTED
01
02
03
04
05
06
Additional
equipment Check items
COMMENT
Sheet 27
NOTES
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .............................. ............................................................. . . . . . . . . .