Professional Documents
Culture Documents
| select from TB
Rebuild more control points - select
+ Rebuild
control points in select + explode + F10
polysurface -
loft 2+ lines to surface - select 2
lines + loft
contour
steps from
contour
revolve If offset, make sure to close
it -fillet and join
EMAP
pipe
loft
Record history Press before doing the
object to make the object
follow the changes
matchsurface
LAYOUT
projecttocplane
trim
clippingplane
Make2d Ground, section
layering
rotate
layout
Scale the layout Select border+click detail on
the right . set it to 1 mm is to
.2meters (1:200)
Change layer
properties
References -not
part
Pimpmydrawing
website
Hatch error If hatch doesn’t work try
this. Or rebuild it with
smaller controlpts
Select line+rebuild+adjust
Eg. 2650 to 1000