Lifts are a better way to reach overhead areas and are Don’t overload (two people max.). safer than ladders. However, there are safety Don’t use if work platform is damaged. precautions that must be followed. Don’t use near moving vehicles. Don’t stand or sit on guardrails. Don’t override safety devices. Don’t leave unattended with key in switch. Don’t use ladder or other device to increase size or working height. Don’t use with improperly inflated tires. Don’t use with damaged wheels or tires.
Work platform is to be used by trained and
certified operators only. It is the operator’s responsibility to: Hazards/Precautions Read and understand all caution and danger Tip-Over Hazards warnings and operating manual. Don’t drive near drop-offs, holes, or loading decks. Perform daily maintenance inspection. Don’t raise platform on uneven or soft surfaces. Have all worn or damaged parts replaced. Don’t drive onto uneven, soft surfaces when elevated. Fasten entry gate/chain/bar. Don’t raise platform on slope or drive onto slope when Use work platform only on hard level surfaces. elevated. Don’t raise platform in windy or gusty conditions. Reposition the lift rather than standing on the railing to Operator’s Checklist Inspect and/or test the following daily or at the reach the work area. beginning of each shift Don’t travel to job location with lift when in elevated Operating and emergency controls position. Safety devices Don’t remove railing. Personal protective equipment Don’t use lifts near power lines. Electrocution Hazard Tires and wheels This machine is not insulated. Maintain safe clearances Air, hydraulic and fuel system for leaks from electrical power lines and apparatus. You must Loose or missing parts allow for platform, sway, rock, or sag. This work Cable and wiring harness platform does not provide protection from contact with Placards, warnings, control markings and operating or proximity to an electrically charged conductor. manual Guardrail system Battery fluid level Hydraulic reservoir level Coolant level
Follow the safety signs on the machine. Follow the safety signs on the machine.