[262oebo
¥Fig.20 (above): this is the actual size artwork far the
5
SS
OFF CONTINUOUS
+ ' t
POWER INTERMITTENT
ZENZA
apr
MIN MAX MIN MAX
PULSE RATE PULSE WIDTH |
ge
3 a iL 7
se ae:
LEVEL
1 QO.
0..
OUTPUT
PC board. Chack your board carefully against this
‘pattern before installing any of the parts.
ig.12 fright): actual the size artwork for the front
Hr TENS
(Transcutaneous Electrical Neural Stimulation)
panel.
Put; some multimeters may give dif-
forent readings
With intermittent mode selected,
you should see the voltage changing
from OV to a higher reading,
Using TENS
Connect the electrodes to the TENS
unit using the 2.5mm plug to2x 2mm
probe load as supplied with the alec-
trodas. If you wish to make your own
leads, the 2mm probes are available
from Dick Smith Electronics (Cat. P-
The electrodes should be
Y° jelly (*trade mark
of Johnson & Johnson Pacific) or salt
water solution to provide a reliable
skin contact. They can be attached to
the skin using any of the variety of
tapes used to secure wound dress-
ings. Attach the electrodes in position
on either side of the pain source.
Before switching on the TENS Unit
be sure that the voltage is tumed down
tothe minimum. Wind the voltage up
‘until sensation can be folt and adjust
7 =)
the pulse rate and width far the do.
sived effect. The voltage will need to
be wound up curing treatment to cam
ensate for the body's adaptation to
tho stimulation. The intermittent so
lection is usod whoro tho treatment
period is long {aormal treatmont ses-
sions are typically for 20 minutas) or
‘where the user finds the continuous
effect to be waning,
Further detaiis on the TENS treat-
ment techniquescan be obteined fram
your General Practitioner. sc