Professional Documents
Culture Documents
VYJESH M.V
The relay will operate only if the logic high, the output pin 11 of the 'D' sequence by taking one's own time. For
correct number is selected. For example, NAND gate also goes high, which in turn example, the number 666 can be selected
suppose the circuit is wired for number switches transistor T1 into conduction by pressing S1, S2 and S3 three times
666. To open the lock, switches S 1, S2 and the relay gets activated. LEDs 1, 2 and again S1, S2 and S3 another three
and S3 must be pushed six times each. and 3 are used to indicate that IC1, IC2 times. Use of good quality, press-to-on
The lock can be wired to operate with and IC3 are reset. The number lock switches is recommended to avoid false
any number from 111 to 999 by simply should not be operated if all the three triggering. The circuit given here is for
changing the output tapping points of LEDs do not glow initially when switch three digits. By increasing the number
IC1 to IC3 from Q1 to Q9 respectively. S4 is put on. If the three LEDs do not of 4017s the number of digits can be
The circuit shown here is wired for glow, then press the on/off-cum-reset increased by using the same logic as
number 666. In the circuit Q6 (pin 5) switch S4 again to reset IC1, IC2 and given in this circuit idea.
ELECTRONICS PROJECTS