Professional Documents
Culture Documents
D1603
Introduction
Carbon Black is one of the most
important filler in plastics materials.
It not only acts as pigment but also
as an UV absorber. However, the
level of addition of this filler
influences the plastics behavior a lot
and hence, requires to be well
controlled. This is major reason of
determining the percentage of it in
given polymer mass.
This test method is used to determine the average carbon black content in materials like plastic pipes, films,
sheets, cables, water tanks. The test is often used as a quality control measurement for black polyolefin. This is
particularly more effective in polyolefin and polyethylene.
Salient features
Heavy & thick heat insulation providing to eliminate radiation of heat
Attractive powder coated body.
Using microprocessor based temperature controller
Providing m/c leveling arrangement for flow level of gas.
All glassware accessories are of "BOROSIL" make.
Nitrogen gas cylinder has to be arranged by the operator. (It will not be supplied with the instrument)
Technical specification
Power supply : 230 Volt, 50 Hz, single phase, AC supply
Heater Capacity : 2.0 KW
Heating Range : 5 0°C to 1000°C
Heating control : Through Programmable microprocessor based PID controller having facility of overshoot
control
Accuracy : ± 5.0°C
Pyrolising Chamber : Heat resistant quartz glass tubular
Pretreatment : De-oxygenating unit and de-humidifying unit
Gas Flow Control : Through a single stage regulator and with flow meter
Sample Holder : Quartz Glass Boat of 12mm diameter and 125mm long
post Treatment : Double Dissolution Unit