Professional Documents
Culture Documents
Unit 9 - Week 8: Assignment No. 8
Unit 9 - Week 8: Assignment No. 8
reviewer1@nptel.iitm.ac.in ▼
Unit 9 - Week 8
Course
outline Assignment No. 8
The due date for submitting this assignment has passed. Due on 2018-04-04, 23:59 IST.
How to access
the portal Submitted assignment
Week 7 2) The load at which failue has occurred can be measured from 1 point
Service history
Week 8
Experimental stress analysis
Lecture 36- Fracture toughness testing
General
Hardness testing
procedure of
failure analysis:
No, the answer is incorrect.
Question for
analysis
Score: 0
Accepted Answers:
Lecture 37-
General
Experimental stress analysis
procedure of
3) Checking of adequacy of cross sectional area of the failed component needs information 1 point
FA: Reporting
failure analysis about
and failure
analysis of Service load
welded joint Mechanical properties
Lecture 38- Geometry of the component and other features present
General All of above
procedure of
failure analysis: No, the answer is incorrect.
Failure analysis Score: 0
of weld joint
Accepted Answers:
Lecture 39- All of above
General
procedure of 4) Reporting of failure analysis should be 1 point
failure analysis:
Examples of Clear
failure analysis
Concise
Lecture 40- Logical
General
procedure of All of above
https://onlinecourses.nptel.ac.in/noc18-me29/unit?unit=13&assessment=62 1/3
21/05/2018 Failure analysis and Prevention - - Unit 9 - Week 8
failure analysis: No, the answer is incorrect.
Embrittlement of Score: 0
steels
Accepted Answers:
Quiz : All of above
Assignment No.
8 5) Failure of a weldment can occur from 1 point
Solution for
Weld metal
Assignment No.
8 Heat affected zone
Base metal
DOWNLOAD
VIDEOS Any location of weldment as per the base metal and welding process used for joining
6) Throat thickness of the groove weld in a joint of dissimilar thickness plates is obtained from 1 point
Creep conditions
Deformation
Fatigue
Static loading
8) Carbon steel having hardness greater than 450 HV, can experience hydrogen induced 1 point
cracking if the hydrogen content is more than
0.03 PPM
0.3 PPM
3 PPM
30 PPM
Cast iron
Austenitic stainless steel
Martensitic stainless steel
Low alloy steel
https://onlinecourses.nptel.ac.in/noc18-me29/unit?unit=13&assessment=62 2/3
21/05/2018 Failure analysis and Prevention - - Unit 9 - Week 8
10)Embrittlement of the Steel in molten Zn is observed due to 1 point
350 °C embrittlement
Sigma phase embrittlement
Graphitisation
Liquid metal embrittlement
Funded by
Powered by
https://onlinecourses.nptel.ac.in/noc18-me29/unit?unit=13&assessment=62 3/3