Professional Documents
Culture Documents
----
install.
Choose shape:
Define two extruders
Calibration
1) level
Like this
Then, we could command “G29”
Calculation and
2) Re define the maxium height.
Descending the nozzle, until it reach the plate, then, read the value of
how to print
1) What file
2) method
manager:
configuration.
After this. We can slice a *.stl file now
Then, we can print now
Tip: when you print, the distance between nozzle and plate should be
0.3mm or so, if the distance is too big, the structure would be loose too,
Combine two parts of *.stl . (using slicer.exe, this file refer to the
fileslink. )
Refer to pic below,(this is a part of whole pic, the whole picture refer to
The pic above is about how to combine two *.stl file to one object that
After these two process, dual printer could print a (two colors, or two
material ) object.
Thank you !
email: sales@reprap.cn