Professional Documents
Culture Documents
Transformers
There are, however, two other types of losses; extra losses created by harmonics and losses which
may apply particularly to larger transformers – cooling or auxiliary losses, caused by the use of
cooling equipment like fans and pumps.
No-Load losses
These losses occur in the transformer core whenever the transformer is energised (even when the
secondary circuit is open). They are also called iron losses or core losses and are constant.
Hysteresis losses
Caused by the frictional movement of magnetic domains in the core laminations being magnetized
and demagnetized by alternation of the magnetic field. These losses depend on the type of
material used to build a core.
Silicon steel has much lower hysteresis than normal steel but amorphous metal has much better
performance than silicon steel. Nowadays hysteresis losses can be reduced by material processing
such as cold rolling, laser treatment or grain orientation.
Hysteresis losses are usually responsible for more than a half of total no-load losses (~50% to
~70%).
This ratio was smaller in the past (due to the higher contribution of eddy current losses particularly in
relatively thick and not laser treated sheets).
Caused by varying magnetic fields inducing eddy currents in the laminations and thus
generating heat.
These losses can be reduced by building the core from thin laminated sheets insulated from each
other by a thin varnish layer to reduce eddy currents. Eddy current losses nowadays usually
account for 30% to 50% of total no-load losses. When assessing efforts in improving distribution
transformer efficiency, the biggest progress has been achieved in reduction of these losses.
There are also marginal stray and dielectric losses which occur in the transformer core, accounting
usually for no more than 1% of total no-load losses.
Load losses
These losses are commonly called copper losses or short circuit losses. Load losses vary according
to the transformer loading.
They are composed of:
Sometimes referred to as copper loss, since this resistive component of load loss dominates. This
loss occurs in transformer windings and is caused by the resistance of the conductor.
The magnitude of these losses increases with the square of the load current and is proportional to
the resistance of the winding. It can be reduced by increasing the cross sectional area of conductor
or by reducing the winding length. Using copper as the conductor maintains the balance between
weight, size, cost and resistance; adding an additional amount to increase conductor diameter,
consistent with other design constraints, reduces losses.
Eddy currents, due to magnetic fields caused by alternating current, also occur in the windings.
Reducing the cross-section of the conductor reduces eddy currents, so stranded conductors are
used to achieve the required low resistance while controlling eddy current loss.
Effectively, this means that the ‘winding’ is made up of a number of parallel windings. Since each
of these windings would experience a slightly different flux, the voltage developed by each would
be slightly different and connecting the ends would result in circulating currents which would
contribute to loss.
This is avoided by the use of continuously transposed conductor (CTC), in which the strands
are frequently transposed to average the flux differences and equalise the voltage.
Auxiliary losses
These losses are caused by using energy to run cooling fans or pumps which help to cool larger
transformers.
Advertisement
Guide information
Selecting Energy Efficient Distribution Transformers – A Guide for
Title: Achieving Least-Cost Solutions by Intelligent Energy Europe
Programme
Format: PDF
Size: 2.5 MB
Pages: 32
Download: Please login first | Get Download Updates | Get Technical articles
Recommended EE articles
Subscribe to Monthly Download Updates
Get EEP's updates without having to keep checking up on the portal to see if there is anything
new. New FREE technical articles, electrical books, guides, software and other exclusive content
you will receive via email. Pretty simple!
Subscribe here:
Email Address:
Subscribe
Become EEP's Contributor and introduce yourself to 70k+ of our readers all across the web.
© 2013 EEP - Electrical Engineering Portal. All Rights Reserved | Privacy Policy | 44 queries in
0.821 seconds.
TOP Powered by CsanyiGroup