Professional Documents
Culture Documents
product
guide
features
• All New Design contents
• 90' Four-Section Boom Features 2
• 20 Ton Rating
Mounting Configurations 3
• Self-lubricating “Easy Glide” Wear Pads
• Internal Anti-two-block Specifications 4
• Auxiliary Stabilizers
Capacities: With 45' Jib 5
• Variable
Displacement
Hydraulic System
Capacities: No Jib 6
Accessories 7
features
Why Buy a National Series 600E?
– All outrigger, lift and telescoping cylinders are manufactured to National Crane Designs, so
that the seals, packing glands, and end plates are traced for accurate shipment of
replacement parts.
– National has a formalized quality program and is ISO 9001 approved.
• National Crane Is a Quality Product That Will Provide Years of Service
– Parts are available for all National Crane machines, even if they are over 20 years old.
mounting configurations
The configurations are based on the Series 600E with an 85% stability factor. The complete unit must be installed in accordance with
factory requirements and a test performed to determine actual stability and counterweight requirements since individual truck chassis vary.
components of the vehicle (axles, tires, springs, frame, • The complete unit must be installed in accordance with
etc.) meeting manufacturers’ recommendations: always factory requirements, and a test performed to determine
specify GVWR when purchasing trucks actual stability and counterweight requirements per SAE
• Diesel engines require a variable speed governor and J765; contact the factory for details
energize-to-run fuel solenoid for smooth crane operation; • Transmission neutral safety interlock switch is required
electronic fuel injection requires EET engine remote with optional remote control
throttle
*Estimated axle scale rates prior to installation of crane, stabilizers and subbase for 85% stability.
specifications
Boom and Jib Combinations Data
Available in five basic models.
Model 638E – Equipped with a 16-38 ft. (4.88-11.58 m) three-section boom. Maximum tip height is 48 ft.
4 (14.63 m) (no jib option available).
16-38 ft. (4.88-11.58 m) three-section boom.
Model 647E – Equipped with19-47 ft. (5.79-14.33 m) three-section boom. This model can be equipped
with an 18-29 ft. (5.49-8.84 m) two section jib. Maximum tip height w/29 ft. (8.84 m) jib is 86 ft. (26.24 m).
19-47 ft. (5.79-14.33 m) three-section boom.
19-47 ft. (5.79-14.33 m) three-section boom. 6FJ29M 18-29 ft. (5.49-8.84 m) two-section jib
Model 671E – Equipped with a 27-71 ft. (8.23-21.64 m) three-section boom. This model can be equipped
with a 25-45 ft. (7.62-13.72 m) two-section jib. Maximum tip height w/45 ft. (13.72 m) jib is 125 ft. (38.25 m).
27-71 ft. (8.23-21.64 m) three-section boom.
27-71 ft. (8.23-21.64 m) three-section boom. 6FJ45M 25-45 ft. (7.62-13.72 m) two-section jib
Model 680E – Equipped with a 24-80 ft. (7.32-24.38 m) four-section boom. Maximum tip height is 90 ft.
(27.44 m). (no jib option available).
24-80 ft. (7.32-24.38 m) four-section boom.
Model 690E – Equipped with a 27-90 ft. (8.23-27.43 m) four-section boom. This model can be equipped
with a 25-45 ft. (7.62-13.72 m) two section jib. Maximum tip height w/45 ft. (13.72 m) jib is 144 ft.(43.95 m).
27-90 ft. (8.23-27.43 m) four-section boom.
27-90 ft. (8.23-27.43 m) four-section boom. 6FJ45M 25-45 ft. (7.62-13.72 m) two-section jib
Other series 600E Load Rating Charts are available. National will send you a chart on request – or you may secure needed
load rating information through your nearest National dealer.
O C CO CAUTION:
5
• Do not operate crane booms, jib extensions, any
160 accessories or loads within 10 ft (3m) of live power lines
2nd Jib
80˚ or other conductors of electricity.
45 ft 70˚
140 • Jib and boom capacities shown are maximum for each
60˚
57.5˚
section.
1st Jib • Do not exceed capacities at reduced radii
25 ft
120 • Load ratings shown on the load rating charts are maximum
allowable loads with the outriggers properly extended on a
firm, level surface and the crane leveled and mounted on a
BOOM LENGTH IN FEET
90 50˚
46.5˚ 100
factory recommended truck.
HEIGHT IN FEET
78
• Always level the crane with the level indicator located on
66 80 the crane.
40˚ Do not • The operator must reduce load to allow for factors such as
54 extend
jib into wind, ground conditions, operating speeds and their effects
30˚ 60
41 this on freely suspended loads.
20˚
area • Overloading this crane may cause structural collapse or
27 40 instability.
10˚
• Weights on any accessories attached to the boom or
loadline must be deducted from the load chart capacities.
20 • Do not exceed jib capabilities at any reduced boom lengths.
A B C D 0˚
-10˚ • Do not deadhead lineblock against boom tip when
0 extending boom or winching up.
0 20 40 60 80 100 120 • Keep at least three wraps of loadline on drum at all times.
RADIUS IN FEET • Use only specified cable with this machine.
NOTE:
1. Operate with jib by radius when
main boom is fully extended. If LOADLINE EQUIPMENT
necessary increase boom angle to
SERIES 690E maintain loaded radius.
DEDUCT (lb)
WITH 2. Operate with jib by boom angle Downhaul weight 150
45 FT JIB when main boom is not fully One sheave block 200
extended. Do not exceed rated jib Two sheave block 355
capacities at any reduced boom
lengths.
THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and
other instructional plates must be read and understood prior to operating the crane.
capacities
Load Rating Chart: Series 690E with No Jib
Other series 600E Load Rating Charts are available. National will send you a chart on request – or you may secure needed
load rating information through your nearest National dealer.
6
120 CAUTION:
• Do not operate crane booms, jib extensions,
80˚ any accessories or loads within 10 ft (3m) of
90 70˚
100 live power lines or other conductors of
60˚ electricity.
78
• Jib and boom capacities shown are maximum for
50˚
BOOM LENGTH IN FEET
66 80 each section.
• Do not exceed capacities at reduced radii
HEIGHT IN FEET
40˚
54 • Load ratings shown on the load rating charts are
30˚ 60 maximum allowable loads with the outriggers
41 properly extended on a firm, level surface and the
20˚
crane leveled and mounted on a factory
27 40 recommended truck.
• Always level the crane with the level indicator
10˚
located on the crane.
20
• The operator must reduce load to allow for factors
0˚ such as wind, ground conditions, operating speeds
-10˚
A B C D
and their effects on freely suspended loads.
• Overloading this crane may cause structural
0
collapse or instability.
0 20 40 60 80 100
• Weights on any accessories attached to the boom
RADIUS IN FEET
or loadline must be deducted from the load chart
capacities.
• Do not exceed jib capabilities at any reduced
boom lengths.
LOADLINE EQUIPMENT • Do not deadhead lineblock against boom tip when
SERIES 690E DEDUCT (lb) extending boom or winching up.
WITH Downhaul weight 150 • Keep at least three wraps of loadline on drum at
NO JIB One sheave block 200 all times.
Two sheave block 355 • Use only specified cable with this machine.
75 11 450 33 1,150
80 26.5 800
85
0 4,150 0 1,950 0 850
THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and
other instructional plates must be read and understood prior to operating the crane.
accessories
Radio Remote Controls –
Eliminate the handling and maintenance concerns that accompany • Model R4R
cabled remotes. Operate to a range of about 250 feet (76 m), varying with conditions.
One-Person Basket – 7
Strong but lightweight steel basket with 300-lb (139-kg) capacity, gravity • Model B1-S
hung with swing lock and full body harness. • Model 2B1-S (for dual locking baskets)
Continuous Rotation –
Allows rotation of turret/boom without rotation stop. • Model CR
Dimensions Specifications
600E
Manitowoc Crane Group - Americas
Manitowoc, Wisconsin Facility
Tel: [Int + 001] 920 684 6621
Fax: [Int + 001] 920 683 6277
Shady Grove, Pennsylvania Facility
Tel: [Int + 001] 717 597 8121
Fax: [Int + 001] 717 597 4062
Distributed By:
Constant improvement and engineering progress make it necessary that we reserve the right to make
specification, equipment, and price changes without notice. Illustrations shown may include optional equipment
and accessories, and may not include all standard equipment.
www.manitowoccranegroup.com