Professional Documents
Culture Documents
Troubleshooting BGP
Event log messages
For more information, see the Event Log Message Reference Guide.
Display BGP peer information using the show ip bgp neighbor command. A connection to a peer has
not been established.
Analysis
To become BGP peers, any two routers need to establish a TCP session using port 179 and exchange open
messages successfully.
Solution
1. Use the show ip bgp neighbor command to verify the peer’s IP address.
2. If the loopback interface is used, check whether the neighbor connect interface command is
configured.
3. If the peer is a non-direct eBGP peer, check whether the neighbor ebgp multihop command is
configured.
6. Use the display tcp status command to check the TCP connection.
1 of 2 17/09/2021, 2:03 PM
Troubleshooting BGP https://techhub.hpe.com/eginfolib/networking/docs/switches/K-KA-K...
prev up next
2 of 2 17/09/2021, 2:03 PM